| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 83 |
| Registration plate issues | 38 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Windscreen washer not working | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 5 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Registration plate lamp issues | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 2 |
| Nearside Reversing lamp inoperative (4.6.1 (a)) | 2 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted near wheel arch (6.1.4 (a) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road above 10mm damage in zone A (3.2 (a) (ii)) | 1 |
| Offside Front Front fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar fractured (5.3.3 (b) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative Headlamp washers are not working (4.1.6 (a) (ii)) | 1 |
| Offside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Road wheel more than one fixing missing (5.2.1 (a) (ii)) | 1 |
| Offside Windscreen damaged and affecting the drivers view of the road damage >10mm in zone A (3.2 (a) (ii)) | 1 |
| Offside Headlamp light intensity severely reduced and flickering (4.1.4 (a)) | 1 |
| Exhaust has a major leak of exhaust gases centre pipe cracked (6.1.2 (a)) | 1 |
| Nearside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Offside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Suspension system inoperative (5.3.5 (a)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative P.R.S offside & nearside, filled reservoir with fluid, no further fault found (4.1.6 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn inner bush separated from arm (5.3.4 (a) (i)) | 1 |
| Electronic parking brake warning indicates a malfunction on dashboard (1.1.6 (e)) | 1 |
| Front Headlamp not working on main beam Both Sides (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Central Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Front Inner Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases centre exhaust pipe holed (6.1.2 (a)) | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen both working washer jets propel fluid over the top of the screen, and not into the swept area (3.5 (a)) | 1 |
| Nearside Front Front fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn REAR Suspension arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative washer fluid low (4.1.6 (a) (ii)) | 1 |
| Offside Front Headlamp cleaning device for LED or HID headlamp inoperative washer fluid low (4.1.6 (a) (ii)) | 1 |
| Offside Side repeater light intensity significantly reduced (4.4.3 (a)) | 1 |
| Offside Rear Rear fog lamp lens defective such that emitted light is adversely affected (4.5.1 (b) (ii)) | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Front fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Seat belt buckle not functioning as intended dog lead stuck in buckle unable to test belt (7.1.2 (d)) | 1 |
| Central Front Headlamp cleaning device for LED or HID headlamp inoperative Headlamp washers no function (4.1.6 (a) (ii)) | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Emissions not tested excessive engine noise (8.2.1.2 (d)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn arm inner bush separated (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn inner bush separated (5.3.4 (a) (i)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Lower trail arm bush split with play (5.3.4 (a) (i)) | 1 |
| Front Service brake excessively fluctuating both (1.2.1 (e)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn OSF lower arm bush at subframe split and excessive movement on wheel play detectors. (5.3.4 (a) (i)) | 1 |
| Offside Front Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working Both if fitted in a pair (4.5.1 (a) (ii)) | 1 |