| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Registration plate issues | 13 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Brake pipe excessively corroded | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Front brake disc in such a condition that it is seriously weakened | 6 |
| Registration plate lamp issues | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Front brake excessively fluctuating | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Windscreen has damage | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Direction indicator not working (1.4.A.2c) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Emissions not tested Due to leak (8.2.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases Both silencers (6.1.2 (a)) | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt rubber split open (6.1.7 (g) (ii)) | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Parking brake operation grabbing severely |3.7.C.3b| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Front Headlamp levelling device inoperative broken/insecure rubbing on driveshaft (4.1.5 (a)) | 1 |
| Front Side repeater incorrect colour both (4.4.3 (a)) | 1 |
| Nearside Rear Exhaust emissions likely to be affected by an exhaust leak marked with yellow chalk (8.2.1.1 (b)) | 1 |
| Offside Rear Exhaust emissions likely to be affected by an exhaust leak marked with yellow chalk (8.2.1.1 (b)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Front front brakes release unevenly |3.7.B.4| | 1 |
| Brake performance unable to be tested Due to condition of front brakes (1.2.1 (g)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Power steering pipe/hose excessively corroded from steering rack |2.1.5 |g| |i|| | 1 |
| Power steering pipe/hose leaking from steering rack |2.1.5 |a|| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Offside Rear Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |