| Most common failures | No# failures |
|---|
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 23 |
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Headlamp aim out of alignment | 14 |
| Registration plate lamp issues | 12 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 9 |
| Brake pipe excessively corroded | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Rear parking brake recording little or no effort | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Horn not working |1.6.2a| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Registration plate issues | 5 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear Anti-roll bar fractured |2.4.G.1| | 2 |
| Offside Rear Anti-roll bar fractured |2.4.G.1| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Rear brake application uneven | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Centre Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Anti-roll bar fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases pipe loose & clamps corroded & broken (6.1.2 (a)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Trailing arm severely distorted |2.4.G.1| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Anti-roll bar linkage likely to become detached |5.3.3 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage insecure and impairing directional stability |5.3.3 |a| |ii|| | 1 |
| Offside Rear Anti-roll bar linkage insecure and impairing directional stability |5.3.3 |a| |ii|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced both lenses poor condition |1.7.5a| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Stop lamp|s| showing white light to the rear |4.3.3 |a| |ii|| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Outer Rear Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded chassis rail |2.4.A.3| | 1 |
| Offside Outer Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction sticker on windscreen (3.1 (a) (ii)) | 1 |
| Rear Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect bulb incorrectly fitted or lens deteriorated (4.1.2 (c)) | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Access panel cannot be secured in the closed position |6.4.1| | 1 |
| Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive 0.5 |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive 0.5 |7.3.D.3| | 1 |
| Nearside Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Exhaust system insecure |6.1.2 |a|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |