| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 26 |
| Headlamp aim out of alignment | 22 |
| Registration plate lamp issues | 11 |
| Brakes imbalanced across an axle | 8 |
| Horn not working |1.6.2a| | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Horn not working (7.7 (a)) | 4 |
| Brake pipe excessively corroded | 4 |
| Registration plate issues | 3 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 2 |
| Reversing lamp inoperative (4.6.1 (a)) | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Rear brake application uneven | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Steering column locking device insecure |2.1.6| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp insecure Lens fallen off |1.7.3| | 1 |
| Rear brake binding | 1 |
| Fuel system component leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Offside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side not working (1.4.1 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Fuel cap/sealing device ineffective fuel cap not sealing at filler pipe |6.1.3 |b| |i|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing badly holed and corroded at rear of front wheel arch |5.3.6 |a| |i|| | 1 |
| Steering system excessively rough o/s front strut upper bearing seized - spring not located in correct place in seat |2.1.1 |a|| | 1 |
| Front brake excessively fluctuating | 1 |
| Windscreen wiper not working Wipers Won`t park |only work on speed 2| |3.4 |a|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside All direction indicators not working When hazard warning light switched on |4.4.1 |a| |ii|| | 1 |
| Offside Rear Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Offside Front Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Front Steering linkage insecure to the extent there is excessive movement at the mountings Steering link arm n/s/f bush |2.1.3 |a| |ii|| | 1 |
| Front Steering linkage insecure to the extent there is excessive movement at the mountings Steering pivot rearmost |2.1.3 |a| |ii|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak Exhaust snapped (8.2.1.1 (b)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Steering linkage insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Emissions not tested due to exhaust leak (8.2.1.2 (d)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Nearside Front Seat belt missing |7.1.2 |a|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits due to exhaust leak |8.2.1.2 |c|| | 1 |
| Rear Exhaust has a major leak of exhaust gases exhaust box leaking badly corroded through |6.1.2 |a|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Rear Prop shaft joint excessively worn joint to axle |6.1.7 |c| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength chassis rail both sides (5.3.6 (a) (i)) | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail,sub frame mount (5.3.6 (a) (i)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Offside Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Horn control insecure |1.6.1| | 1 |
| Central Front Steering linkage modification unsafe Steering idler arm bushes excessively worn. (2.1.3 (f) (i)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Direction indicator not working whole side (4.4.1 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn inner pin/bush (5.3.4 (a) (i)) | 1 |