| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Brake pipe excessively corroded | 5 |
| Brake load sensing valve linkage seized |3.6.E.3| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Headlamp aim not tested |1.8.A.1c| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear brake application uneven | 2 |
| Horn not working |1.6.2a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Brakes imbalanced across an axle | 2 |
| Registration plate lamp issues | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Fuel system component leaking under bonnet (6.1.3 (b) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Upper Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Front Upper Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Vehicle structure inadequately repaired such that structural rigidity is significantly reduced underside (6.1.1 (d) (i)) | 1 |
| Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced x member (6.1.1 (c) (i)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Brake pipe likely to become detached or damaged all where not clipped (1.1.11 (d) (ii)) | 1 |
| Suspension component mounting prescribed area is inadequately repaired underside (5.3.6 (a) (i)) | 1 |
| Seat belt anchorage prescribed area is inadequately repaired underside (7.1.1 (a) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside An item not tested |Manual| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Rear brake binding | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Lower Stop lamp not working |1.2.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake pump/compressor retaining device insecure bracket broken |3.6.A.2d| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust silencer likely to become detached several mounting rubbers missing (8.1.1 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |