| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 22 |
| Brake pipe excessively corroded | 12 |
| Rear brake binding | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Brake hose excessively deteriorated | 8 |
| Registration plate lamp issues | 8 |
| Offside Steering rack gaiter split |2.2.D.2d| | 7 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 6 |
| Registration plate issues | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear brake application uneven | 4 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Brakes imbalanced across an axle | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Fuel pipe leaking |7.2.3| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Centre Rear Seat belt stitching badly frayed |5.2.2b| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Towbar component excessively corroded |6.6.1| | 1 |
| Nearside Front position lamp|s| missing |1.1.A.3a| | 1 |
| Offside Rear Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Rear Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Steering wheel locking device missing |2.1.6| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Brake cable locking device insecure |3.5.1l| | 1 |
| Windscreen wiper blade insecure | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Windscreen washer not working | 1 |
| Nearside Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Power steering ram|s| leaking from a failed seal |2.3.3b| | 1 |
| Front Lower Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Brake valve leaking |3.6.A.1| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Power steering pump insecure |2.3.6| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Front Power steering ram|s| leaking from a failed joint |2.3.3b| | 1 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |