| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 25 |
| Brake pipe excessively corroded | 16 |
| Headlamp aim out of alignment | 10 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Brakes imbalanced across an axle | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Front brake disc excessively pitted |3.5.1h| | 3 |
| Offside Front coil spring fractured |2.4.C.1a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Rear brake application uneven | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 2 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
| Windscreen wiper blade insecure | 2 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear Brake lining|s| insecure |3.5.1g| | 1 |
| Nearside Rear Rear position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Upper Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Centre Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front front brake grabbing severely |3.7.A.2b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor |chassis rail| within seat mounting area |5.2.6| | 1 |
| Nearside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Rear Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Registration plate issues | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear coil spring cracked |2.4.C.1a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Centre Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Direction indicator adversely affected by the operation of another lamp n/s rear |1.4.A.2h| | 1 |
| Stop lamp not working o/s rear |1.2.1b| | 1 |
| Anti-roll bar rubber mounting deteriorated resulting in excessive movement o/s rear |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Front brake application uneven | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Brake lever locking device missing |3.5.1l| | 1 |
| Offside Rear Brake lever locking device missing |3.5.1l| | 1 |