Most common failures | No# failures |
---|
Registration plate lamp issues | 29 |
Headlamp aim out of alignment | 26 |
Windscreen wiper does not clear the windscreen effectively | 26 |
Brakes imbalanced across an axle | 15 |
Horn not working |1.6.2a| | 13 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 11 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Parking brake: efficiency below requirements |3.7.B.7| | 8 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 8 |
Offside Stop lamp not working |1.2.1b| | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 7 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
Rear brake binding | 7 |
Brake pipe excessively corroded | 6 |
Rear parking brake recording little or no effort | 6 |
Brake hose excessively deteriorated | 6 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Front brake application uneven | 4 |
Registration plate issues | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Rear Exhaust system not adequately supported |7.1.1| | 4 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Nearside front brake binding |3.7.B.1| | 3 |
Offside front brake juddering severely |3.7.A.2b| | 3 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
Offside Front front brake binding |3.7.B.1| | 3 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Battery insecure |1.9.1| | 3 |
Hazard warning lamps inoperative |1.4.B.1b| | 3 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 3 |
Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 3 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 3 |
Stop lamp remains on when the brakes are released | 3 |
Front front brake binding |3.7.B.1| | 2 |
Windscreen has damage | 2 |
Nearside front brake juddering severely |3.7.A.2b| | 2 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
Offside Rear coil spring fractured |2.4.C.1a| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
Driver`s seat insecure |6.2.A.1| | 2 |
Nearside Obligatory mirror insecure |8.1.1| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Rear brake application uneven | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
Horn emits two or more alternating tones |1.6.2d| | 2 |
Rear Brake pipe leaking |3.6.A.1| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Obligatory mirror insecure |8.1.1| | 2 |
Front passenger seat insecure |6.2.3| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Front Torsion bar deteriorated by corrosion so that its cross sectional area is reduced and seriously weakened |2.4.E.1b| | 1 |
Offside Front Torsion bar deteriorated by corrosion so that its cross sectional area is reduced and seriously weakened |2.4.E.1b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Steering system fouling |2.2.D.2a| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front An item not tested |Manual| | 1 |
Offside Front An item not tested |Manual| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Rear Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Headlamp missing |1.7.3| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Centre Exhaust mounting missing |7.1.1b| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Nearside Front passenger door hinge insecure |6.2.B.2| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front passenger door hinge deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Offside Rear Fuel hose insecure |7.2.1| | 1 |
Offside Rear Fuel hose excessively chafed |7.2.2| | 1 |
Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor |5.3.6 |a| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Rear Brake hose inappropriately repaired |3.6.A.3| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Offside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Anti-roll bar locating pin retaining device not properly locked |2.4.G.3b| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Rear Coil spring mounting damaged and seriously weakened |2.4.C.3c| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Rear Radius arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
Offside Rear Radius arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
Offside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear front brake binding |3.7.B.1| | 1 |
Offside Rear front brake binding |3.7.B.1| | 1 |
Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front brake caliper locking device missing |3.5.1l| | 1 |
Offside Front brake caliper locking device missing |3.5.1l| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Brake performance not tested copper pipe snapped |3.7.A.1| | 1 |
Nearside Front Brake pipe leaking copper pipe snapped |3.6.A.1| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Driver`s seat insecure |6.2.A.1| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Offside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Nearside Rear All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Offside Rear All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Service brake juddering severely |3.7.C.2| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Inner Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Outer Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside Outer Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Brake pipe inappropriately repaired |3.6.A.3| | 1 |
Offside Front Brake pipe inappropriately repaired |3.6.A.3| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Front Shock absorber has an excessively worn linkage |2.7.4| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Front Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Front Steering locking device insecure |2.2.C.1g| | 1 |
Offside Front Steering locking device insecure |2.2.C.1g| | 1 |
Steering rack insecure |2.2.B.1a| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Steering system fouling |2.2.D.2a| | 1 |
Offside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Track rod end loose |2.2.B.1d| | 1 |
Offside Track rod end loose |2.2.B.1d| | 1 |
Nearside Front Brake hose leaking |3.6.A.1| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Brake cable locking device insecure |3.5.1l| | 1 |
Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
Offside Rear Shock absorber insecure |2.7.2b| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Brake operation has insufficient reserve pressure/vacuum to provide assistance for at least two more brake applications after the gauge has reached the warning mark |3.3.E.5a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Mechanical brake component has restricted free movement | 1 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Body has a sharp edge caused by corrosion hole in top of wing |6.1.C.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill panel |2.4.A.3| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded outer sill panel |5.2.6| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Inner Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |