| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 4 |
| Registration plate lamp issues | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Registration plate issues | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust system not adequately supported exhaust to turbo loose & bolts missing |7.1.1| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bearing track control arm inner rose joint worn out |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Lower Suspension arm locating pin locking device missing Split pin missing |2.4.G.3b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust system not adequately supported front bracket missing |7.1.1| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |