| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Brakes imbalanced across an axle | 7 |
| Brake pipe excessively corroded | 7 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 5 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Registration plate issues | 3 |
| Registration plate lamp issues | 3 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Front Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen has damage | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Steering box has excessive free play detected at the steering wheel |steering box fitted| linkage |2.3 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Emissions not tested rear exhaust pipe missing |7.3.A.1| | 1 |
| Exhaust has a major leak of exhaust gases rear pipe missing |7.1.2| | 1 |
| Nearside Front Lower Shock absorber insecure |2.7.2b| | 1 |
| Nearside Rear Lower Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Central Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Rear Coil spring mounting corroded and seriously weakened |5.3.1 |b| |i|| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |5.3.1 |b| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring mounting |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear chassis rail |5.3.6 |a| |i|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Front Prop shaft joint excessively worn both joints worn (6.1.7 (c) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Emissions not tested DUE TO EXHAUST LEAK AND CONDITION (8.2.2.2 (e)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Seat belt anchorage loose Buckle (7.1.1 (b)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt outer |6.1.7 |g| |ii|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Anti-roll bar ball joint likely to become detached drop link |5.3.4 |a| |ii|| | 1 |
| Nearside Front Intermediate drop arm deformed to the extent that steering is affected bushes in steering component |2.1.3 |c| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Rear Upper Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Brake prescribed area is excessively corroded inner wheel arch (1.1.21 (e) (i)) | 1 |
| Offside Front Inner Brake master cylinder/servo mounting prescribed area is excessively corroded Wing (1.1.21 (e) (i)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced Wing (7.1.1 (a) (i)) | 1 |
| Offside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired crossmember (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired crossmember (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Offside Front Vehicle structure is so deformed it is likely to adversely affect braking or steering (6.1.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc BOTH OUTER |2.5.C.1a| | 1 |
| Fuel pipe leaking spill off pipe (6.1.3 (b) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Brake master cylinder/servo mounting prescribed area is excessively corroded inner wheel arch (1.1.21 (e) (i)) | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front drive shaft coupling is excessively worn both hardy spicers |2.5.C.1c| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Wheel nut|s| missing x1 |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing x2 |4.2.A.1e| | 1 |
| Offside Front Sub-frame corroded and seriously weakened rear |5.3.3 |b| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring mount and chassis |5.3.6 |a| |i|| | 1 |
| Driver`s airbag obviously inoperative |7.1.5 |c|| | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values |8.2.2.2 |f|| | 1 |
| Offside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front front parking |secondary| brakes imbalanced |3.7.B.6b| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D bush |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength OFFSIDE REAR CHASSIS MEMBER (5.3.6 (a) (i)) | 1 |