| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 23 |
| Headlamp aim out of alignment | 22 |
| Registration plate lamp issues | 19 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Registration plate issues | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 3 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 3 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Emissions not tested |7.4.B.1| | 3 |
| Emissions not tested |7.0| | 3 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 3 |
| Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 3 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement d bush |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Position lamp lens seriously defective |4.2.1 |b|| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Central Front Steering component deformed to the extent that steering is affected Steering damper damaged and distorted restricting steering movement. (2.1.3 (c) (ii)) | 1 |
| Offside Rear Upper Other passenger door hinge missing Rear door hinge missing at time of test. (6.2.3 (c) (ii)) | 1 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Front Fluid leak harmful to the environment or a risk to other road users swivel pin hub seal |8.4.1 |a| |i|| | 1 |
| Offside Front Shock absorbers likely to become detached broken |5.3.2 |a| |ii|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Rear Stop lamp|s| not working both sides |4.3.1 |a| |ii|| | 1 |
| Offside Rear Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected |4.4.1 |b| |ii|| | 1 |
| Nearside Front Direction indicator not working and rear when side lamps on |4.4.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Front Exhaust system insecure flexi pipe to front down pipe |6.1.2 |a|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Brake performance unable to be tested LEAKING (1.2.1 (g)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Rear Exhaust silencer insecure |8.1.1 |b| |i|| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill end (7.1.1 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D-Bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D-Bush (5.3.4 (a) (i)) | 1 |
| Offside Front Road wheel more than one fixing missing (5.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Side repeater missing |4.4.1 |a| |ii|| | 1 |
| Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
| Fuel tank leaking |6.1.3 |b| |i|| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Shock absorber detached |2.7.2b| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Front Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Axle king pin is loose in the axle beam so loose that oil is draining from oil seal (5.1.2 (d) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Central Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Track rod end ball joint has excessive play t/rod end worn and securing split pin missing |2.2.B.1f| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Outer Brake disc in such a condition that it is seriously weakened very badly pitted 60% face |1.1.14 |a| |ii|| | 1 |
| Central Front Brake pedal anti-slip provision missing brake pedal rubber off |1.1.2 |c|| | 1 |
| Nearside Front Outer Anti-roll bar mounting has an unsafe modification anti roll bar bolt snapped and has been welded and weld has broken |5.3.3 |c| |i|| | 1 |
| Offside Front Outer Anti-roll bar mounting has an unsafe modification anti roll bar mount bolt has snapped and been welded |5.3.3 |c| |i|| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pedal anti-slip provision missing |1.1.2 |c|| | 1 |
| Brake load sensing valve seized but ABS functioning load sensing valve seized solid |1.1.17 |c| |i|| | 1 |
| Brake pedal anti-slip provision missing clutch pedal rubber missing |3.3.A.1b| | 1 |
| Nearside Front Upper Brake pipe leaking on an air braking system pipe on chassis behind n/s/f wheel leaking (1.1.11 (b) (i)) | 1 |
| Steering damper excessively corroded and unserviceable |2.2.C.1d| | 1 |
| Offside Front Inner Braking system leaking brake fluid leak o/s/f pipe behind wheel on chassis |3.6.A.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Emissions not tested exhaust broken |8.2.2.2 |e|| | 1 |
| Fluid leak harmful to the environment or a risk to other road users fuel |8.4.1 |a| |i|| | 1 |
| Offside Front Oil leaking excessively from transmission hub swivle joint seal (8.4.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Shock absorbers insecurely attached Snapped near lower mounting point. (5.3.2 (a) (i)) | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit plate value 0.72 (8.2.2.2 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Offside Front Fluid leak harmful to the environment or a risk to other road users hub seal (8.4.1 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases rear pipe broken off (6.1.2 (a)) | 1 |
| Emissions not tested due to exhaust broken (8.2.2.2 (e)) | 1 |
| Nearside Front Shock absorbers likely to become detached |5.3.2 |a| |ii|| | 1 |
| Offside Front Shock absorbers likely to become detached |5.3.2 |a| |ii|| | 1 |
| Offside Front Suspension component insecurely attached bump stop |5.3.3 |a| |i|| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Emissions unable to be completed noise when revs increased. (8.2.2.2 (e)) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Nearside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Electrical wiring damaged and bare wires exposed at rear axel |1.9.2c| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear Direction indicator not working |1.4.A.2c| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 1 |
| Nearside Rear Direction indicator incorrect colour lens broken |1.4.A.2f| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush both front bushes |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush both front bushes |2.4.G.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Anti-roll bar missing |2.4.G.1| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Rear Electrical wiring damaged and bare wires exposed next to axle broken wires |1.9.2c| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases exhaust box missing
|7.1.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner and outer sill area holed and corroded along its length (6.2.2 (d) (i)) | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner and outer sill area holed and corroded along its length (6.2.2 (d) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body mount holed and corroded (6.2.2 (d) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust emissions exceed manufacturers specified limit limit 0.72 (8.2.2.2 (a)) | 1 |
| Nearside Front Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
| Exhaust emissions exceed manufacturer`s specified limit limit 0.72 |8.2.2.2 |a|| | 1 |
| All position lamps not working o/s/f |1.1.A.3b| | 1 |
| Trailer electrical socket insecure rear |1.9.3a| | 1 |
| Statutory seat belt of the wrong type. middle belt stuck under seat |5.1.1| | 1 |
| Stop lamp not working o/s/r |1.2.1b| | 1 |
| Steering damper inappropriately modified bolt loose |2.2.C.1e| | 1 |
| Front wheel bearing has excessive play n/s/f |2.5.A.3c| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Inner Brake disc in such a condition that it is seriously weakened |1.1.14 |a| |ii|| | 1 |
| Offside Rear Inner Brake disc in such a condition that it is seriously weakened |1.1.14 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Steering arm modified such that the steering is adversely affected panard rod (2.1.3 (f) (ii)) | 1 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 1 |
| Exhaust has a major leak of exhaust gases rear section corroded and split (6.1.2 (a)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Anti-roll bar linkage ball joint excessively worn both sides front (5.3.4 (a) (i)) | 1 |