| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 197 |
| Windscreen wiper does not clear the windscreen effectively | 174 |
| Registration plate lamp issues | 83 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 65 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 60 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 53 |
| Registration plate issues | 53 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 51 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 51 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 46 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 45 |
| Parking brake lever has no reserve travel |3.1.6b| | 42 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 41 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 39 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 38 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 38 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 37 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 35 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 35 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 31 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 29 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 26 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 25 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 24 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 24 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 24 |
| Driver`s seat insecure |6.2.A.1| | 23 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 23 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 23 |
| Nearside Stop lamp not working |1.2.1b| | 22 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 22 |
| Windscreen washer not working | 22 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 22 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 22 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 21 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 20 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 19 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 19 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 18 |
| Rear brake disc in such a condition that it is seriously weakened | 18 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 17 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 16 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 16 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 16 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 15 |
| Rear brake binding | 15 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Anti-lock braking system warning lamp indicates an ABS fault | 15 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 15 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 15 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 15 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 14 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 14 |
| Rear Exhaust system not adequately supported |7.1.1| | 13 |
| Front brake disc in such a condition that it is seriously weakened | 13 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 12 |
| Offside Stop lamp not working |1.2.1b| | 12 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 11 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 10 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 10 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 10 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 10 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 10 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 10 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 10 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 10 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Horn not working |1.6.2a| | 9 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 9 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 9 |
| Brakes imbalanced across an axle | 9 |
| Rear parking brake recording little or no effort | 9 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 9 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 9 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 9 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 9 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
| Windscreen has damage | 8 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 8 |
| Brake hose excessively deteriorated | 8 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 8 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 7 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 7 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 7 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 7 |
| Battery insecure |1.9.1| | 7 |
| Offside Front Position lamp not working |4.2.1 |a|| | 7 |
| Rear Mechanical brake component has restricted free movement | 7 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 7 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 7 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 7 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 7 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 7 |
| Offside Rear Stop lamp not working |1.2.1b| | 6 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 6 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 6 |
| Nearside Rear Stop lamp not working |1.2.1b| | 6 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 6 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 6 |
| Nearside Front Shock absorbers has a serious fluid leak | 6 |
| Offside Front Shock absorbers has a serious fluid leak | 6 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 6 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 6 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 6 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Horn not working (7.7 (a)) | 6 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 5 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
| Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 5 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 5 |
| Emissions not tested |7.3.A.1| | 5 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Rear Shock absorbers has a serious fluid leak | 5 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 5 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 5 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 5 |
| Nearside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 5 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 5 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 5 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 5 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 5 |
| Emissions not tested (8.2.1.2 (d)) | 5 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 5 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 5 |