| Most common failures | No# failures |
|---|
| Rear parking brake recording little or no effort | 11 |
| Battery insecure |1.9.1| | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Registration plate lamp issues | 6 |
| Offside Steering rack gaiter split |2.2.D.2d| | 6 |
| Brake pipe excessively corroded | 6 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 6 |
| Headlamp aim out of alignment | 6 |
| Registration plate issues | 6 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brakes imbalanced across an axle | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Front brake excessively fluctuating | 2 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Rear reflector missing |1.5.1a| | 2 |
| Rear brake binding | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside rear brake recording little or no effort park |3.7.B.5a| | 1 |
| Centre Seat belt locking mechanism does not secure or release middle |5.2.5a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner and outer sill |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Vehicle structure has excessive damage seriously affecting its strength within 30cm of a towbar mounting inner valance |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting inner valance |6.6.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Exhaust has a major leak of exhaust gases middle box |6.1.2 |a|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings Inner Sill |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner Sill |6.1.B.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded Inner Sill |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded Inner Sill |5.2.6| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Cross Member |6.1.B.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Front Exhaust has a major leak of exhaust gases down pipe |7.1.2| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill corroded |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill corroded |6.1.B.2| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp incorrect colour |1.7.5b| | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Horn not working |1.6.2a| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Windscreen has damage | 1 |
| Offside Outer Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Central Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
| Body component likely to become detached skirts - o/s + n/s |6.2.1 |a| |ii|| | 1 |
| Nearside Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill - front to rear |5.3.6 |a| |i|| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Central Front Seat belt buckle not functioning as intended |7.1.2 |d|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint linkarm |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Body has a sharp edge caused by damage light lens |6.1.C.1| | 1 |
| Nearside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement in centre |2.4.G.2| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Seat belt not functioning as intended Both rear (7.1.2 (c)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Steering column has an unsafe modification Live Electric cable fouling steering universal joint. (2.2.2 (e)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill after wheel (6.1.1 (c) (i)) | 1 |