| Most common failures | No# failures |
|---|
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Registration plate lamp issues | 5 |
| Headlamp aim out of alignment | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Battery insecure |1.9.1| | 2 |
| Brake pipe excessively corroded | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Rear Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Leaf spring shackle pin locking device insecurely fitted |2.4.B.3b| | 1 |
| Offside Rear Leaf spring shackle pin locking device insecurely fitted |2.4.B.3b| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Outer Stop lamp not working |1.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Power steering component|s| leaking from a failed seal Rack |2.3.3b| | 1 |
| Steering arm has relative movement at its fixings Both |2.2.B.1h| | 1 |
| Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt Both front |2.4.G.2| | 1 |
| Road wheel fractured Nearside rear |4.2.B.1a| | 1 |
| Exhaust has a major leak of exhaust gases Front |7.1.2| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering arm repaired by welding |2.2.C.1e| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Registration plate issues | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Centre Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Power steering pump drive system defective drive belt loose causing judder of assistance. |2.3.6| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Front Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn front bush on arm (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |