Most common failures | No# failures |
---|
Windscreen wiper does not clear the windscreen effectively | 63 |
Headlamp aim out of alignment | 36 |
Registration plate lamp issues | 34 |
Rear brake binding | 19 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 16 |
Parking brake: efficiency below requirements |3.7.B.7| | 15 |
Anti-lock braking system warning lamp indicates an ABS fault | 11 |
Registration plate issues | 11 |
Offside Front position lamp|s| not working |1.1.A.3b| | 10 |
Parking brake lever has no reserve travel |3.1.6b| | 9 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Rear parking brake recording little or no effort | 8 |
Emissions not tested |7.0| | 7 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 7 |
Brake pipe excessively corroded | 6 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
Rear brake disc in such a condition that it is seriously weakened | 5 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
Centre Stop lamp not working |1.2.1b| | 5 |
Rear brake application uneven | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
Brakes imbalanced across an axle | 4 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Rear Mechanical brake component has restricted free movement | 3 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Offside Rear fog lamp not working |1.3.2b| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 2 |
Centre Upper Stop lamp not working |1.2.1b| | 2 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Rear brake disc excessively scored |3.5.1h| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside front brake juddering severely |3.7.A.2b| | 2 |
Offside front brake juddering severely |3.7.A.2b| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Headlamp cleaning device obviously defective |1.7.2| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Lower Rear fog lamp not working |1.3.2b| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded floorpan |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded floorpan |2.4.A.3| | 1 |
Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Front Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Nearside Rear Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Offside Front Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Offside Rear Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Offside Front Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Headlamp aim beam image kick up to the offside |1.8| | 1 |
Rear fog lamp missing |1.3.2a| | 1 |
Side repeater missing |1.4.A.2b| | 1 |
Windscreen washer not working | 1 |
Nearside Front Lower Suspension arm ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
Headlamp has a product on the lens so that the light output is severely reduced Both side |4.1.4 |b|| | 1 |
Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Nearside Front Shock absorbers has a serious fluid leak | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Emissions not tested due to burst exhaust |7.4.B.1| | 1 |
Front Exhaust has a major leak of exhaust gases flexible section |7.1.2| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Parking brake lever has no reserve travel & poor effort |3.1.6b| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Power steering fluid level below minimum |2.3.1| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Headlamp cleaning device inoperative |1.7.2| | 1 |
Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Centre Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Nearside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Front Headlamp has a product on the lens so that the light output is severely reduced both sides |4.1.4 |b|| | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Front Steering rack gaiter insecure small end |2.2.D.2d| | 1 |
Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced len`s |1.7.5a| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced len`s |1.7.5a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
Battery leaking electrolyte |1.9.1| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sil |6.1.1 |c| |i|| | 1 |
Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sil |6.1.1 |c| |i|| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
Offside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Mechanical brake component securing device missing |3.5.1i| | 1 |
Offside Headlamp cleaning device obviously defective |1.7.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front crossmember |6.1.B.2| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
Offside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
Offside Headlamp levelling device inoperative |1.7.2| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Anti-roll bar linkage which is adjustable, locking device missing |2.4.G.1| | 1 |
Offside Front Anti-roll bar linkage which is adjustable, locking device missing |2.4.G.1| | 1 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength outer sill holed (5.3.6 (a) (i)) | 1 |
Offside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
Offside Front Shock absorbers has a serious fluid leak | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Nearside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Outer Sill (6.1.1 (c) (i)) | 1 |
Rear Shock absorbers has a serious fluid leak BOTH (5.3.2 (b)) | 1 |
Front Suspension arm pin or bush excessively worn BOTH (5.3.4 (a) (i)) | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |