| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 35 |
| Headlamp aim out of alignment | 30 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 26 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 23 |
| Registration plate lamp issues | 20 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 13 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 12 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 10 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 10 |
| Windscreen washer not working | 9 |
| Brakes imbalanced across an axle | 9 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 8 |
| Registration plate issues | 7 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Rear fog lamp switch missing (4.5.3 (a)) | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 6 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 5 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Brake pipe excessively corroded | 5 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Front Position lamp not working |4.2.1 |a|| | 4 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 3 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 3 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 3 |
| Front brake excessively fluctuating | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Windscreen has damage | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Front Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Nearside Front Suspension arm pin or bush likely to become detached rear bush (5.3.4 (a) (ii)) | 2 |
| Offside Front Suspension arm pin or bush likely to become detached rear bush (5.3.4 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Horn not working |1.6.2a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Rear Emissions not tested Back box full of water, slight blow (8.2.1.2 (d)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake fluid not visible (1.1.10 (d) (iii)) | 1 |
| Offside Rear Hydraulic brake calliper damaged and braking performance affected (1.1.16 (a) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working o/s/f side light not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn excessive wear in o/s/f lower ball joint (5.3.4 (a) (i)) | 1 |
| Nearside Rear Other passenger door likely to open inadvertently or not remain closed (6.2.3 (b) (ii)) | 1 |
| Front Position lamp not working NS and OS (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Middle and rear blowing (6.1.2 (a)) | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Sub-frame pin or bush excessively worn back (5.3.4 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
| Exhaust has a major leak of exhaust gases Middle to Back Box (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Front brake application uneven | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn arm rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear Bush (5.3.4 (a) (i)) | 1 |
| Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Exhaust has a major leak of exhaust gases tail pipe |7.1.2| | 1 |
| Emissions not tested blown rear exhaust |7.3.A.1| | 1 |
| Nearside Front Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement Back |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement Back |2.4.G.2| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Rear Exhaust silencer likely to become detached pipe fractured most of the way around at front end of silencer (8.1.1 (b) (ii)) | 1 |
| Front Sub-frame insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Rear Seat belt webbing significantly weakened cut from edge greater than 2mm (7.1.2 (b)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Brake pedal functionally incomplete |3.3.A.1a| | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases joint (6.1.2 (a)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Front Inner Brake disc contaminated Excessive corroded (1.1.14 (b)) | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Rear Inner Brake disc significantly and obviously worn SURFACE (1.1.14 (a) (i)) | 1 |
| Brake hydraulic reservoir cap missing |1.1.10 |e|| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn Wishbone (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested exhaust |7.3.A.1| | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Central Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction sticker |3.1 |a| |ii|| | 1 |
| Rear Reversing lamp inoperative |4.6.1 |a|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases pipe split at rear joint |7.1.2| | 1 |
| Brake pedal pivot has excessive wear or free play (1.1.1 (b)) | 1 |
| Offside Front Brake disc significantly and obviously worn inner face (1.1.14 (a) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Central Rear Seat belt buckle not functioning as intended wont lock (7.1.2 (d)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Central Exhaust shield missing where fitted as original equipment creating a risk of fire (6.1.3 (e)) | 1 |
| Rear Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Anti-roll bar linkage ball joint excessively worn both front (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Position lamp not working side (4.2.1 (a) (ii)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Front Headlamp aim beam image kick up to the offside both |1.8| | 1 |
| Front Headlamp aim beam image kick up to the offside both sides |1.8| | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn Link rod (5.3.4 (a) (i)) | 1 |
| Rear Exhaust shield missing where fitted as original equipment creating a risk of fire at fuel tank (6.1.3 (e)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment (1.1.15 (f)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn back bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn back bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding wheel bearing not checked (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding wheel bearing not checked (1.2.1 (f)) | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush |bonding gone| |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush |bonding gone| |5.3.4 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn excessively pitted (1.1.14 (a) (i)) | 1 |
| Offside Front Brake performance unable to be tested disc excessively pitted (1.2.1 (g)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Emissions unable to be completed rear silencer missing (8.2.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases rear silencer missing (6.1.2 (a)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |