| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 12 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 12 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Rear brake binding | 8 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Headlamp aim out of alignment | 4 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Registration plate lamp issues | 3 |
| Registration plate issues | 3 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Offside Obligatory mirror missing |8.1.1| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Rear brake application uneven | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced spring hanger area (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded floor |2.2.C.1h| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Brake clevis joint locking device missing |3.5.1l| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested due to engine failure |7.3.A.1| | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear Leaf spring anchor bracket corroded and seriously weakened front mount |2.4.B.6d| | 1 |
| Rear Brake cable insecure | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint trinion |2.5.B.1a| | 1 |
| Nearside Front Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Seat belt anchorage loose |7.1.1 |b|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Body component corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Offside Rear Body component corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Fuel pipe leaking |7.2.3| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Front Driver`s seat insecure |6.2.A.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Front All direction indicators not working both (4.4.1 (a) (ii)) | 1 |
| Rear All direction indicators not working both (4.4.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced door stop (7.1.1 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Offside Rear Body component corroded and likely to cause injury wheel arch (6.2.1 (a) (i)) | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Seat belt anchorage prescribed area is inadequately repaired centre floor outriggers to inner sills (7.1.1 (a) (i)) | 1 |
| Nearside Headlamp light intensity severely reduced dip beam (4.1.4 (a)) | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Headlamp light intensity severely reduced main beam (4.1.4 (a)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill corroded and holed (7.1.1 (a) (i)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt rubber boot split (2.1.3 (g) (ii)) | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill / floor holed |7.1.1 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer/inner sill/floor pan (7.1.1 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor/jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor/jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front position lamp|s| not working near side |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |