| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Brakes imbalanced across an axle | 6 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Registration plate lamp issues | 5 |
| Rear parking brake recording little or no effort | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Horn not working |1.6.2a| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear brake binding | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Direction indicators not working |1.4.A.2c| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Headlamp aim out of alignment | 3 |
| Windscreen washer not working | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Central Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross-member |6.1.B.2| | 1 |
| Central Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassie |6.1.B.2| | 1 |
| Offside Brake pipe inadequately clipped from master to front |3.6.B.1| | 1 |
| Central Brake pipe inadequately clipped to rear |3.6.B.1| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` wiper arms |8.3.1e| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Front suspension locking device missing |2.5.A.4| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| All position lamps not working |4.2.1 |a|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner door sill |6.1.1 |c| |i|| | 1 |
| Front Windscreen wiper control missing |8.2.1a| | 1 |
| Front Windscreen washer control missing |8.2.1a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Inner Parking brake mechanism/associated mounting prescribed area is inadequately repaired |3.1.9| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Front Lower Suspension component likely to become detached Trunion Excessive play (5.3.3 (a) (ii)) | 1 |
| Offside Front Upper Suspension component likely to become detached Trunion excessive play (5.3.3 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers damaged to the extent that it does not function Twisted mount (5.3.2 (b)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Driver`s seat insecure |6.2.A.1| | 1 |
| Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded Inner sill |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded Inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded Front of spring hanger |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded Front of spring hanger |2.4.A.3| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Torque/reaction arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Torque/reaction arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear wheel cylinder securing device excessively deteriorated |3.5.1j| | 1 |