| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 21 |
| Horn not working |1.6.2a| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Windscreen washer not working | 5 |
| Registration plate lamp issues | 5 |
| Rear Stop lamp not working |1.2.1b| | 5 |
| Registration plate issues | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 3 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear brake binding | 2 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Stop lamp(s) switch with a delay in operation (4.3.2 (a) (ii)) | 1 |
| Nearside Front Position lamp not working inner and outer |4.2.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| All position lamps not working |4.2.1 |a|| | 1 |
| Brake pedal anti-slip provision worn smooth |1.1.2 |c|| | 1 |
| Electrical wiring likely to drag on the ground Near N/S/R leaf spring |4.11 |a| |iii|| | 1 |
| Electrical wiring insulation so damaged or deteriorated it is likely to cause a short-circuit Near N/S/R leaf spring |4.11 |c| |ii|| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Position lamp not working all front side lamps not working (4.2.1 (a) (ii)) | 1 |
| Rear Position lamp not working all rear side lamps not working (4.2.1 (a) (ii)) | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Nearside Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Offside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Steering system excessively rough (2.1.1 (a)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Front Suspension arm attachment bracket/mounting damaged and its strength is seriously reduced Lower cross member |2.4.G.1| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Centre Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Nearside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Front Steering rack insecure |2.2.B.1a| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. Can only be secured at furthest back position, chassis impedes operation/function (6.2.5 (b) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Lower Suspension rod insecurely attached bottom of leg |5.3.3 |a| |i|| | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Horn not working (7.7 (a)) | 1 |