| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 32 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Offside Stop lamp not working |1.2.1b| | 15 |
| Nearside Stop lamp not working |1.2.1b| | 14 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 12 |
| Offside Rear fog lamp not working |1.3.2b| | 10 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 9 |
| Rear fog lamp not working |1.3.2b| | 9 |
| Registration plate lamp issues | 9 |
| Brakes imbalanced across an axle | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 9 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 8 |
| Offside Steering rack gaiter split |2.2.D.2d| | 7 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 7 |
| Stop lamp not working |1.2.1b| | 7 |
| Rear fog lamp tell tale not working |1.3.1b| | 6 |
| Rear Stop lamp not working |1.2.1b| | 6 |
| Horn not working |1.6.2a| | 6 |
| Registration plate issues | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Centre Steering rack gaiter split |2.2.D.2d| | 6 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Centre Stop lamp not working |1.2.1b| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear brake binding | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Rear fog lamp switch faulty |1.3.1a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 3 |
| Nearside Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Offside Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Lower Steering column universal joint insecure |2.1.5| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Nearside Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Centre Obligatory mirror missing |8.1.1| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Offside Front Tie bar/rod insecure |2.4.G.1| | 1 |
| Rear Brake clevis joint insecure parking brake securing split pin missing (1.1.15 (c)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Offside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Outer Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Horn control missing |1.6.1| | 1 |
| Offside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Stop lamp(s) all missing (4.3.1 (a) (iii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Rear brake application uneven | 1 |
| Stop lamp not working all 3 |intermittent, brake light switch requires replacement/ adjustment| |1.2.1b| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush nut missing |2.5.A.1c| | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Lower Coil spring missing rebound spring. sliding pillar suspension. (5.3.1 (c) (i)) | 1 |
| Nearside Steering damper fractured and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Trailing arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Suspension component pin or bush excessively worn King Pin Bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension component pin or bush excessively worn King Pin Bush (5.3.4 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Steering column universal joint retaining device insecure |2.1.6| | 1 |
| Nearside Inner Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Inner Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front suspension has excessive movement at a tie bar joint |2.5.A.1c| | 1 |
| Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Offside Front Lower Steering column locking device insecure |2.1.6| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Steering locking device insecure |2.2.C.1g| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Nearside Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Steering column locking device insecure |2.1.6| | 1 |
| Nearside Front Tie bar/rod attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested has major leak (8.2.1.2 (d)) | 1 |
| Rear fog lamp switch not operating in accordance with the requirements (4.5.3 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Stop lamp not working All |1.2.1b| | 1 |
| Offside Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Centre Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt small split ns of rack boot (2.1.3 (g) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Service brake excessively binding both rear (1.2.1 (f)) | 1 |
| Offside Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |