Most common failures | No# failures |
---|
Brake pipe excessively corroded | 23 |
Headlamp aim out of alignment | 21 |
Registration plate lamp issues | 16 |
Windscreen wiper does not clear the windscreen effectively | 16 |
Parking brake: efficiency below requirements |3.7.B.7| | 9 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 7 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 7 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 7 |
Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
Offside Stop lamp not working |1.2.1b| | 7 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 6 |
Nearside Stop lamp not working |1.2.1b| | 6 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Rear parking brake recording little or no effort | 4 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
Brakes imbalanced across an axle | 3 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 3 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Windscreen washer not working | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
Emissions not tested (8.2.1.2 (d)) | 2 |
Offside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Registration plate issues | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
Anti-lock braking system warning lamp indicates an ABS fault | 2 |
Nearside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Battery insecure |1.9.1| | 2 |
Nearside Front Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Front Outer Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement both sides of car |2.4.G.2| | 1 |
Rear Exhaust has a major leak of exhaust gases silencer joint |7.1.2| | 1 |
Nearside Outer Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Outer Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Rear fog lamp not working bad connection (4.5.1 (a) (ii)) | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Body component likely to become detached side step |6.2.1 |a| |ii|| | 1 |
Nearside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
Offside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Anti-roll bar rubber bush deteriorated resulting in excessive movement near side and offside bushes worn |2.4.G.2| | 1 |
Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
Offside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Rear Exhaust emissions likely to be affected by an exhaust leak silencer pipe broken (8.2.1.1 (b)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Rear Exhaust system not adequately supported back box tail pipe |7.1.1| | 1 |
Rear Exhaust has a major leak of exhaust gases rear back box tail pipe broke |7.1.2| | 1 |
Steering lock stop incorrectly adjusted (2.1.4 (b)) | 1 |
Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Rear Exhaust system insecure (6.1.2 (a)) | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Track rod end ball joint has excessive play steering idler (2.1.3 (b) (i)) | 1 |
Nearside Body component likely to become detached door step (6.2.1 (a) (ii)) | 1 |
Offside Body component likely to become detached door step (6.2.1 (a) (ii)) | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush on lower arm |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement d bush on lower arm |2.4.G.2| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear coil spring broken |2.4.C.1a| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Brake pipe at imminent risk of failure or fracture along chassis front to back (1.1.11 (a)) | 1 |
Nearside Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Exhaust has a major leak of exhaust gases manifold |6.1.2 |a|| | 1 |
Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis in places (5.3.6 (a) (i)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively damaged significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis in places (5.3.6 (a) (i)) | 1 |
Outer Anti-roll bar pin or bush excessively worn both front outer (5.3.4 (a) (i)) | 1 |
Anti-roll bar pin or bush excessively worn both rear (5.3.4 (a) (i)) | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Anti-roll bar pin or bush excessively worn both front outer (5.3.4 (a) (i)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits fast idle test both carbon monoxide and lambda outside limits
second fast idle only lambda outside limits (8.2.1.2 (c)) | 1 |
Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
Nearside Front Steering locking device insecure |2.2.C.1g| | 1 |
Offside Steering locking device missing |2.2.C.1g| | 1 |
Brake pipe at imminent risk of failure or fracture FRONT TO REAR(by tank) (1.1.11 (a)) | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Front front brake juddering severely |3.7.A.2b| | 1 |
Rear front brake juddering severely |3.7.A.2b| | 1 |
Exhaust has a major leak of exhaust gases Center Box Pipe Broken |7.1.2| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear Rear fog lamp does not emit a steady red light showing white light to the rear lens broken (4.5.4 (a)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Brake pipe leaking on a hydraulic braking system front to rear (1.1.11 (b) (ii)) | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis x2 places |2.4.A.3| | 1 |
Nearside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Headlamp aim projected beam image is obviously incorrect Both. (4.1.2 (c)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded central chassis rail |2.4.A.3| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement x 2 |2.4.G.2| | 1 |
Front Headlamp has a product on the light source so that the light output is severely reduced x 2 |1.7.5a| | 1 |
Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Offside Front Outer Steering locking device ineffective lock nut not tightened (2.1.3 (d)) | 1 |
Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Rear fog lamp does not emit a steady red light x2 |1.3.2e| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear reflector more than 50% obscured |1.5.1b| | 1 |