| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 56 |
| Headlamp aim out of alignment | 42 |
| Windscreen wiper does not clear the windscreen effectively | 32 |
| Registration plate lamp issues | 27 |
| Nearside Stop lamp not working |1.2.1b| | 15 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 13 |
| Brakes imbalanced across an axle | 13 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 13 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 11 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
| Offside Stop lamp not working |1.2.1b| | 8 |
| Rear brake binding | 8 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Rear Exhaust system not adequately supported |7.1.1| | 7 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Registration plate issues | 5 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Emissions not tested |7.0| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear parking brake recording little or no effort | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Front brake application uneven | 2 |
| Rear brake application uneven | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Windscreen has damage | 2 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 2 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings CROSSMEMBER |6.1.B.2| | 1 |
| Offside Rear Inner Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
| Nearside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings BOTH FRONT STRUT TOPS |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings BOTH FRONT INNER CHASSIS |6.1.B.2| | 1 |
| Offside Rear Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear Rear reflector excessively deteriorated so that its function is impaired |1.5.1c| | 1 |
| Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis near rear shocker |6.2.2 |d| |i|| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Seat belt anchorage prescribed area is severely distorted floor to sill |5.2.6| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Anti-roll bar severely distorted |2.4.G.1| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings INNER WING |6.1.B.2| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Tie bar/rod attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded Inner And Outer Sill |5.2.6| | 1 |
| Suspension component mounting prescribed area is excessively corroded both rear inner sill ends |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded both rear outer sills |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded both rear inner sills |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded both rear cross member |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded both rear inner wheel arch to boot |2.4.A.3| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Braking system leaking at calliper |3.6.A.1| | 1 |
| Offside Rear Braking system leaking at calliper |3.6.A.1| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Front Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting 2x Corrosion holes (6.1.6 (i) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis 2x corrosion holes (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength 3x corrosion holes (5.3.6 (a) (i)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross member |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings under arch |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings under arch |6.1.B.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded out rigger |2.4.A.3| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded inner arch |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner arch |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded inner arch |5.2.6| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting inner arch |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting inner arch |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting chassis |6.6.6| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting rear panel |6.6.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded rear panel |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded sill end /wheelarch |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded sill /wheel arch |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded suspension top |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded suspension top |2.4.A.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Inner Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Inner Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Inner Rear Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Rear Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Emissions not tested not tested due to leak (8.2.1.2 (d)) | 1 |
| Offside Headlamp not working on dipped beam INTERMITENT ? |1.7.5a| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive 0.530 |7.3.D.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive 0.702 |7.3.D.4| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner arch yellow chalked |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner arch yellow chalked |6.2.2 |d| |i|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting out rigger yellow chakled |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting out rigger yellow chakled |6.2.2 |d| |i|| | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill yellow chalked |6.2.2 |d| |i|| | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Marked with chalk (5.3.6 (a) (i)) | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |