| Most common failures | No# failures |
|---|
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Registration plate issues | 5 |
| Headlamp aim out of alignment | 5 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 4 |
| Rear fog lamp switch missing (4.5.3 (a)) | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Brake pipe excessively corroded | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Registration plate lamp issues | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Emissions not tested CAT MISSING |7.3.A.1| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Oil leaking excessively from engine oil filter (8.4.1 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Track rod end ball joint has excessive play possible inner also (2.1.3 (b) (i)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Front Position lamp adversely affected by the operation of another lamp both side lamp bulbs flickering on and off (4.2.3 (c)) | 1 |
| Offside Front wheel bearing rough when rotated and has play |2.5.A.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust has a major leak of exhaust gases x 2 (6.1.2 (a)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength CHASSIS (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength CHASSIS (5.3.6 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Nearside Headlamp light source and lamp not compatible led bulb fitted (4.1.4 (c)) | 1 |
| Offside Headlamp light source and lamp not compatible led bulb fitted (4.1.4 (c)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Emissions not tested aborted engine surging (8.2.1.2 (d)) | 1 |
| Rear fog lamp switch missing unable to test rear fog light (4.5.3 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Central Exhaust catalytic converter obviously defective (8.2.1.1 (a)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Outer Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |