| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 56 |
| Registration plate lamp issues | 54 |
| Headlamp aim out of alignment | 46 |
| Brake pipe excessively corroded | 26 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 15 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 15 |
| Registration plate issues | 15 |
| Offside Rear fog lamp not working |1.3.2b| | 14 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 12 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 12 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Nearside Stop lamp not working |1.2.1b| | 10 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 9 |
| Offside Stop lamp not working |1.2.1b| | 9 |
| Brakes imbalanced across an axle | 9 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Windscreen has damage | 8 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Rear reflector missing |1.5.1a| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside front brake binding |3.7.B.1| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
| Emissions not tested |7.0| | 3 |
| Rear brake application uneven | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Horn not working |1.6.2a| | 3 |
| Brake load sensing valve seized |3.6.E.3| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 3 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 3 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 3 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside rear brake juddering severely |3.7.A.5b| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Horn not working (7.7 (a)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust system not adequately supported Rear |7.1.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Rear Exhaust silencer likely to become detached |8.1.1 |b| |ii|| | 1 |
| Emissions not tested exhaust broken. |8.2.1.2 |d|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Emissions unable to be completed exhaust detatched. (8.2.1.2 (d)) | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear reflector insecure |1.5.1a| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Rear Spare wheel carrier insecure |6.4.2| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Torque/reaction arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Floor excessively deteriorated |6.2.4 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength leaf spring |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength leaf spring |5.3.6 |a| |i|| | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount |bump stop| |5.3.6 |a| |i|| | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount |bump stop| |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear mount x2 |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength leaf mount x2 |5.3.6 |a| |i|| | 1 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Rear Stop lamp|s| showing white light to the rear |4.3.3 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Passenger`s seat with a defective structure |6.2.6 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Inner Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear reflector insecure |1.5.1a| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| An item not tested |Manual| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Offside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn drop link (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn drop link (5.3.4 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor (6.2.2 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |