| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Headlamp aim out of alignment | 15 |
| Brake pipe excessively corroded | 13 |
| Registration plate lamp issues | 9 |
| Brake hose excessively deteriorated | 9 |
| Registration plate issues | 7 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 6 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 6 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 5 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Ball joint has excessive play |2.2.B.1f| | 3 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Emissions not tested |7.0| | 3 |
| Brakes imbalanced across an axle | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Offside Rear fog lamp insecure |1.3.2a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Nearside Front Outer Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Outer Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Exhaust engine idle speed too high |7.3.A.2a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering wheel in a condition that hampers proper control |2.1.1| | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Windscreen has damage | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear brake application uneven | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Centre Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front passenger seat insecure |6.2.3| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear brake binding | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Inner Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Centre Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Rear Rear reflector not red in colour |1.5.1d| | 1 |
| Offside Front Seat belt cut sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area so inadequately repaired that control of the vehicle is likely to be adversely affected SILL (5.3.6 (a) (ii)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area so inadequately repaired that control of the vehicle is likely to be adversely affected SILL (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced CHASSIS CROSS MEMBER (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength SILL (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner and outer sill |2.4.A.3| | 1 |
| Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt steering arm both ends (5.3.4 (b) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |sill| behind and in front of nearside rear wheel |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill behind rear wheel |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings in front of step inner sill |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush outer d bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush outer d bush |2.4.G.2| | 1 |
| Nearside Intermediate drop arm insecure to the extent there is excessive movement at the mountings Steering idler bush has excessive movement. |2.1.3 |a| |ii|| | 1 |
| Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt Four in total. (2.1.3 (g) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Lower Body component corroded and likely to cause injury Door and rear wing (6.2.1 (a) (i)) | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Brake pivot has restricted free movement |3.5.1k| | 1 |
| Offside Brake pivot has restricted free movement |3.5.1k| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Lower Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Dipswitch does not operate immediately when selected on dipped beam (4.1.3 (b)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Front Body panel corroded and likely to cause injury a pillar (6.2.1 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting centre (6.2.2 (d) (i)) | 1 |
| Offside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting centre (6.2.2 (d) (i)) | 1 |
| Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt x3 (2.1.3 (g) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |