| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 13 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Registration plate issues | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Brakes imbalanced across an axle | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Registration plate lamp issues | 2 |
| Headlamp aim out of alignment | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Suspension component mounting prescribed area excessively damaged significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Nearside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Rear brake binding | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill by suspension mounting |2.4.A.3| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength offside & nearside rear inner sill (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor near wishbone mount (5.3.6 (a) (i)) | 1 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Front Service brake excessively binding X 2 (1.2.1 (f)) | 1 |
| Rear Service brake excessively binding X 2 (1.2.1 (f)) | 1 |
| Rear Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Brake hydraulic reservoir fluid not visible (1.1.10 (d) (iii)) | 1 |
| Offside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Front Power steering pipe/hose leaking on steering rack (2.1.5 (a)) | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Rear Power steering component leaking steering rack (2.1.5 (a)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Brake pipe leaking on a hydraulic braking system pipe from master cylinder to abs pump (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Offside Front Headlamp are incorrectly positioned (4.1.4 (a)) | 1 |
| Windscreen washer not working | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill near suspension mount corroded (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill corroded inner and outer (5.3.6 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |