| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 20 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 17 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 16 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Registration plate issues | 13 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 13 |
| Registration plate lamp issues | 9 |
| Brake pipe excessively corroded | 8 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 6 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear fog lamp not working (1.3.2b) | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3) | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 2 |
| Offside Front Brake hose twisted |3.6.B.4c| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Rear Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive (7.3.D.4) | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive (7.3.D.3) | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3) | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Front brake application uneven | 1 |
| Offside front brakes release unevenly |3.7.B.4| | 1 |
| Windscreen has damage | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Macpherson strut insecure |2.4.G.1| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Outer Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Inner Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Front Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose damaged | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Fuel hose insecure |7.2.1| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Rear Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Rear fog lamp tell tale not working (1.3.1b) | 1 |
| Horn not loud enough to be heard by another road user (1.6.2b) | 1 |
| Battery insecure (1.9.1) | 1 |
| Electrical wiring insecure (1.9.2a) | 1 |
| Nearside Front Electrical wiring insecure (1.9.2a) | 1 |
| Offside Front Electrical wiring insecure (1.9.2a) | 1 |
| All position lamps not working (1.1.A.3b) | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush (2.4.G.2) | 1 |
| Fuel hose insecure (7.2.1) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.A.3) | 1 |
| Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Offside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Nearside Headlamp not working on main beam (1.7.5a) | 1 |
| Offside Headlamp not working on main beam (1.7.5a) | 1 |
| Offside Front Front position lamp(s) not working (1.1.A.3b) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Rear Exhaust silencer insecure silencer (8.1.1 (b) (i)) | 1 |