| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 45 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 38 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 31 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 26 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 25 |
| Registration plate lamp issues | 22 |
| Headlamp aim out of alignment | 19 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 10 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Emissions not tested |7.0| | 9 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
| Brakes imbalanced across an axle | 9 |
| Registration plate issues | 9 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Battery insecure |1.9.1| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 6 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brake pipe excessively corroded | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Front brake excessively fluctuating | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Windscreen has damage | 2 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Front brake application uneven | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Rear Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Centre Rear Upper Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Fuel cap/sealing device missing |7.2.4a| | 2 |
| Nearside Inner Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits 0.50 |8.2.1.2 |a|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits 1.45 |8.2.1.2 |c|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Headlamp has a product on the light source so that the light output is severely reduced both |1.7.5a| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Offside Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Offside Rear Lower Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement nearside/offside |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive co 0.58 |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive hc276 |7.3.D.3| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded inner arch to chassis |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded inner arch to chassis |5.2.6| | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area is excessively corroded lower sill to inner wheel arch |5.2.6| | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area is excessively corroded lower sill to inner arch |5.2.6| | 1 |
| Offside Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front coil spring broken |2.4.C.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Centre Lower Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear brake binding | 1 |
| Offside Outer Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Ball joint ball pin shank loose track steering arm inner joint/excessive wear/play |2.2.B.1c| | 1 |
| Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Lower Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Rear brake application uneven | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Nearside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Inner Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Stop lamp adversely affected by the operation of another lamp all |1.2.1f| | 1 |
| Emissions not tested due to oil light coming on |7.3.A.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Front Power steering component|s| leaking from a failed joint |2.3.3b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Fluid suspension unit deteriorated and likely to fail |2.4.D.1b| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |