| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 43 |
| Parking brake: efficiency below requirements |3.7.B.7| | 16 |
| Brake pipe excessively corroded | 15 |
| Offside Steering rack gaiter split |2.2.D.2d| | 13 |
| Rear parking brake recording little or no effort | 13 |
| Brakes imbalanced across an axle | 12 |
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Rear brake disc in such a condition that it is seriously weakened | 7 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 6 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 6 |
| Front brake disc in such a condition that it is seriously weakened | 6 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Offside front brake binding |3.7.B.1| | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Front front brake binding |3.7.B.1| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Brake hose damaged | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Front Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Front Fuel hose so insecure there is a risk of fire fuel filter |6.1.3 |a| |ii|| | 1 |
| Nearside Front Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Headlamp aim not tested no dipped beam |1.8.A.1c| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Axle fractured has a crack near stub axle (5.1.1 (a)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Spare wheel insecure Spare wheel cradle loose & insecure |tightened| |6.4.2| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Offside Rear Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Battery leaking electrolyte |1.9.1| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Rear Axle fractured |5.1.1 |a|| | 1 |
| Nearside Obligatory mirror insecure |3.3 |b| |ii|| | 1 |
| Rear brake binding | 1 |
| Nearside Rear Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust system not adequately supported front mounting detached |7.1.1| | 1 |
| Offside Parking brake efficiency below requirements |3.7.B.7| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting insecure front bolt not fully tight |2.4.G.1| | 1 |
| Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Sub-frame corroded and seriously weakened at the tube wear it bolts to the body (5.3.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn frame to body (5.3.4 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Headlamp has a product on the light source so that the light output is severely reduced both |4.1.4 |b|| | 1 |
| Rear Exhaust system not adequately supported box |7.1.1| | 1 |
| Rear brake application uneven | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Fuel pipe insecure |7.2.1| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Brake pipe inadequately clipped on axle |3.6.B.1| | 1 |
| Central Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Hazard warning lamps operated by more than one switch |1.4.B.1c| | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt BOTH (2.1.3 (g) (ii)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |