| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Registration plate issues | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Brakes imbalanced across an axle | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Registration plate lamp issues | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested rear silencer detached (8.2.1.2 (d)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Steering lock fails to engage |2.1.4b| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Outer Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Electrical wiring insecure and connectors likely to become disconnected (4.11 (a) (ii)) | 1 |
| Offside Rear Vehicle structure inadequately repaired such that structural rigidity is significantly reduced outer sill (6.1.1 (d) (i)) | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Seat belt flexible stalk stretched or damaged likely to lead to failure under load |7.1.2 |b| |ii|| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Steering wheel rim loose (2.2.1 (c) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Power steering component|s| leaking rack |2.3.3b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Macpherson strut insecure and impairing directional stability where mounts to hub (5.3.3 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Battery insecure |1.9.1| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |