| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 51 |
| Windscreen wiper does not clear the windscreen effectively | 34 |
| Registration plate lamp issues | 25 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
| Battery insecure |1.9.1| | 12 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 12 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
| Brakes imbalanced across an axle | 11 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 9 |
| Rear parking brake recording little or no effort | 9 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 8 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 8 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 7 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 5 |
| Horn not working |1.6.2a| | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 5 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Rear brake binding | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Registration plate issues | 2 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside front brake juddering severely |3.7.A.2b| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Windscreen has damage | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting weld cracked |2.4.G.1| | 1 |
| Nearside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Suspension arm pin or bush excessively worn trailing arms /axle both sides |5.3.4 |a| |i|| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear brake disc modified and seriously weakened |3.5.1n| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps excessively deteriorated so that they are not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Hazard warning switch faulty lights don`t stay on when switch is released |1.4.B.1d| | 1 |
| Exhaust system not adequately supported rear bracket corroded and broken |7.1.1| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp(s) missing (4.3.1 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill holed |5.3.6 |a| |i|| | 1 |
| Fluid leak harmful to the environment or a risk to other road users fuel |8.4.1 |a| |i|| | 1 |
| Offside Service brake lagging in operation |1.2.1 |d|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill holedand corroded (5.3.6 (a) (i)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Front Lower Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced lens cloudy |1.7.5a| | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced lens cloudy |1.7.5a| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Obligatory mirror missing (3.3 (a)) | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Front Service brake excessively binding OSF & NSF |1.2.1 |f|| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Front position lamp|s| not working OFFSIDE |1.1.A.3b| | 1 |
| Stop lamp not working NEARSIDE |1.2.1b| | 1 |
| Suspension arm has excessive play in a ball joint NEARSIDE FRONT |2.4.G.2| | 1 |
| Front brake application uneven | 1 |
| Central Rear Seat belt installation has a sharp edge which could or is likely to cut or abrade the webbing. obstructed by dog gaurd |5.3.1b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Emissions not tested DUE TO EXHAUST FALT |8.2.2.2 |e|| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Front Fuel pipe leaking |7.2.3| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Nearside Rear Brake inadequately mounted calliper bolt missing (1.1.21 (c)) | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |