| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Brakes imbalanced across an axle | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear reflector missing |1.5.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Upper Front suspension locking device missing |2.5.A.4| | 1 |
| Offside Rear Road wheel distorted |4.2.A.1a| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Electrical wiring insecure |1.9.2a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Nearside Front Upper Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Brake hose damaged | 1 |
| Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Semaphore indicator arm does not extend smoothly |1.4.C.1a| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim out of alignment | 1 |
| Offside Front Anti-roll bar locating pin incorrectly positioned |2.4.G.3a| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Centre Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Rear position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Offside Rear Leaf spring shackle bracket insecure |5.3.1 |a| |i|| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Front brake application uneven | 1 |
| Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Rear brake application uneven | 1 |
| Nearside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Offside Semaphore indicator arm does not extend smoothly |1.4.C.1a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Semaphore indicator switch missing |1.4.C.1c| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |