| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 21 |
| Brake pipe excessively corroded | 19 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 13 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 9 |
| Brakes imbalanced across an axle | 9 |
| Windscreen washer not working | 8 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 7 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 7 |
| Registration plate lamp issues | 6 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Front brake application uneven | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 3 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 3 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 3 |
| Registration plate issues | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 3 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Rear brake binding | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Sub-frame attachment bracket/mounting fractured excessively corroded |5.3.3 |b| |ii|| | 1 |
| Offside Front Sub-frame attachment bracket/mounting fractured excessively corroded |5.3.3 |b| |ii|| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Offside Rear Anti-lock braking system component excessively damaged ring broken |1.6 |e|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect bulbs fitted incorrectly (4.1.2 (c)) | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Brake clevis joint has restricted free movement cable to caliper |3.5.1k| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Rear Stop lamp(s) not working high level (4.3.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Stop lamp|s| all not working intermitant when lights on |4.3.1 |a| |iii|| | 1 |
| Front Sub-frame attachment bracket/mounting fractured n/s/f corroded |5.3.3 |b| |ii|| | 1 |
| Nearside Front Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Reversing lamp inoperative Modified tail lamp lenses fitted without reverse lamps which would have been present as standard at vehicle manufacture. (4.6.1 (a)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Suspension arm insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Nearside Rear Brake inadequately mounted Bolts loose, |1.1.21 |c|| | 1 |
| Front Service brake lagging in operation |1.2.1 |d|| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Emissions unable to be completed ran out of fuel (8.2.1.2 (d)) | 1 |
| Front Exhaust has a major leak of exhaust gases exhaust flex pipe broken and blowing excessively (6.1.2 (a)) | 1 |
| Front Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength subframe (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength subframe (5.3.6 (a) (i)) | 1 |
| Engine mounting excessively loose (6.1.8 (a) (ii)) | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 1 |
| Rear Sub-frame corroded and seriously weakened mounting points (5.3.3 (b) (i)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Reversing lamp does not emit a steady white light (4.6.2 (a)) | 1 |
| Windscreen has damage | 1 |
| Nearside Brake pipe excessively damaged front to rear (1.1.11 (c)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength Rear sub frame mounting point (5.3.6 (a) (i)) | 1 |
| Front Anti-roll bar linkage pin or bush excessively worn Both (5.3.4 (a) (i)) | 1 |
| Nearside Front Position lamp not working dip beam (4.2.1 (a) (ii)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Wheel nut|s| missing four missing |4.2.A.1e| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Stop lamp(s) not working high level brake light (4.3.1 (a) (ii)) | 1 |
| Reversing lamp inoperative |4.6.1 |a|| | 1 |
| Nearside Front passenger door catch deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Sub-frame attachment bracket/mounting insecure Both front subframe support mounting brackets corroded (5.3.3 (a) (i)) | 1 |
| Speedometer clearly inoperative (7.8 (b) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect bulb fitment incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Supplementary Restraint System warning lamp indicates a fault airbag light on the dash |5.4.2| | 1 |
| Offside Rear Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn chalked track control arm |5.3.4 |a| |i|| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Emissions unable to be completed due to exhaust blow (8.2.1.2 (d)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Ball joint has excessive play track rod end |2.2.B.1f| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Exhaust has a major leak of exhaust gases From the rear section (6.1.2 (a)) | 1 |
| Emissions not tested Due to the condition of the exhaust system (8.2.1.2 (d)) | 1 |
| Stop lamp not working high level lamp |1.2.1b| | 1 |
| Offside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Trailing arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced front bracket |2.4.G.1| | 1 |
| Offside Headlamp aim unable to be tested no pattern (4.1.2 (b)) | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened rear subframe (5.3.3 (b) (i)) | 1 |
| Offside Rear Sub-frame corroded and seriously weakened front subframe (previous unacceptable repair) (5.3.3 (b) (i)) | 1 |
| Sub-frame has an unsafe modification unsafe repair to o/s/f subframe (rear section, patch repaired) (5.3.3 (c) (i)) | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected Near lower arm mount (5.3.6 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |