| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 41 |
| Windscreen wiper does not clear the windscreen effectively | 40 |
| Brakes imbalanced across an axle | 25 |
| Registration plate lamp issues | 22 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 18 |
| Rear parking brake recording little or no effort | 18 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 16 |
| Service brake: efficiency below requirements |3.7.B.7| | 16 |
| Rear brake binding | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 13 |
| Registration plate issues | 12 |
| Rear brake application uneven | 9 |
| Exhaust system not adequately supported |7.1.1| | 8 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 7 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Horn not working |1.6.2a| | 5 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 5 |
| Rear Mechanical brake component has restricted free movement | 5 |
| Brake pipe excessively corroded | 5 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 4 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Battery insecure |1.9.1| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Windscreen washer not working | 4 |
| Emissions not tested |7.0| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 2 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 2 |
| An item not tested |Manual| | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Exhaust mounting missing |7.1.1b| | 1 |
| Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Front Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Emissions not tested very bad coolent leak (8.2.1.2 (d)) | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel system component leaking fuel pump |7.2.3| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside brake caliper leaking |3.6.A.1| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Exhaust has a major leak of exhaust gases centre section |7.1.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Front Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Front Body has a projection caused by damage bumper tow backet |6.1.C.1| | 1 |
| Front Body has a projection caused by damage bonnet stay down clips |6.1.C.1| | 1 |
| Central Front Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Service brake lagging in operation and parking brake is weak |1.2.1 |d|| | 1 |
| Nearside Rear Brake master cylinder leaking wheel cylinder |1.1.10 |b| |ii|| | 1 |
| Nearside Rear Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Offside Rear Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Rear Fuel hose leaking excessively or a risk of fire and fuel cap seal is beginning to perish |6.1.3 |b| |ii|| | 1 |
| Steering column locking device insecure |2.1.6| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Steering column movement between the shaft and steering wheel lower u/j not secure |2.1.2b| | 1 |
| Offside Front Inner Anti-roll bar rubber bush deteriorated resulting in excessive movement bush contaminated by fluid? |2.4.G.2| | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Emissions not tested running hot also engine missfiring (8.2.1.2 (d)) | 1 |
| Windscreen has damage | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt BOTH (2.1.3 (g) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
| Centre Front Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Emissions not tested engine water leak (8.2.1.2 (d)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear Exhaust system insecure mount broken (6.1.2 (a)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake cable inappropriately repaired |3.5.1n| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |