| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 12 |
| Rear brake binding | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Hazard warning switch faulty |1.4.B.1d| | 5 |
| Brakes imbalanced across an axle | 4 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Registration plate lamp issues | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Registration plate issues | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Fuel pipe leaking pump banjos |6.1.3 |b| |i|| | 1 |
| Hazard warning switch faulty Not working |1.4.B.1d| | 1 |
| Hazard warning lamps not fitted |1.4.B.1a| | 1 |
| Offside Rear Braking system leaking Across axle burst on test |3.6.A.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Floor hold |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Inner Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded door step |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded centre/outer cross member |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded front and rear outer castle sections |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded front and rear outer castle sections |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting worn and its strength is seriously reduced trunion bolt hole e-longaited |2.4.G.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear brake application uneven | 1 |
| Brake hose excessively deteriorated | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Fuel pipe leaking |6.1.3 |b| |i|| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Rear Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
| Nearside Front Suspension component pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded wing |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded Valence and body |2.4.A.3| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |