| Most common failures | No# failures |
|---|
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 19 |
| Headlamp aim out of alignment | 15 |
| Registration plate lamp issues | 7 |
| Brakes imbalanced across an axle | 7 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Rear brake binding | 5 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Brake pipe excessively corroded | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Battery insecure |1.9.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Offside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Rear fog lamp not working |1.3.2b| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Rear brake excessively fluctuating | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Upper Seat belt anchorage prescribed area is excessively corroded inner wheel arch |5.2.6| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear Tie bar/rod severely distorted |2.4.G.1| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Offside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Brake pipe excessively damaged at 3 way joiner. (1.1.11 (c)) | 1 |
| Nearside Engine mounting excessively loose (6.1.8 (a) (ii)) | 1 |
| Offside Engine mounting excessively loose (6.1.8 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front suspension has excessive movement at a tie bar joint |2.5.A.1c| | 1 |
| Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |5.3.6 |a| |i|| | 1 |
| Rear Brake pipe connection leaking on a hydraulic braking system on axle |1.1.11 |b| |ii|| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering rack gaiter split (2.2.D.2d) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Headlamp reflector seriously defective (4.1.1 (b) (ii)) | 1 |
| Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front suspension locking device missing |2.5.A.4| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Lower Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions carbon monoxide content excessive CO content too high at 7.09% |7.3.B.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Direction indicators flashing more than 120 times a minute Lamps flashing too fast with hazards switched on. |1.4.A.2g| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Bonnet seriously at risk of opening inadvertently (3.1 (b) (ii)) | 1 |
| Rear Fuel hose leaking |7.2.3| | 1 |
| Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Front Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Brake pipe kinked |3.6.B.2b| | 1 |