Most common failures | No# failures |
---|
Headlamp aim out of alignment | 187 |
Parking brake: efficiency below requirements |3.7.B.7| | 178 |
Registration plate lamp issues | 103 |
Rear parking brake recording little or no effort | 95 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 55 |
Service brake: efficiency below requirements |3.7.B.7| | 45 |
Brake pipe excessively corroded | 40 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 33 |
Brakes imbalanced across an axle | 33 |
Parking brake lever has no reserve travel |3.1.6b| | 30 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 30 |
Windscreen wiper does not clear the windscreen effectively | 30 |
Nearside Stop lamp not working |1.2.1b| | 27 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 26 |
Offside Stop lamp not working |1.2.1b| | 25 |
Rear brake application uneven | 25 |
Rear brake binding | 24 |
Offside Rear fog lamp not working |1.3.2b| | 22 |
Horn not working |1.6.2a| | 22 |
Nearside Side repeater not working |1.4.A.2c| | 20 |
Offside Front position lamp|s| not working |1.1.A.3b| | 19 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 18 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 17 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 16 |
Fuel system component leaking |7.2.3| | 15 |
Battery insecure |1.9.1| | 15 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 13 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 13 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 13 |
Exhaust has a major leak of exhaust gases |7.1.2| | 13 |
Offside Front Direction indicator not working |1.4.A.2c| | 13 |
Nearside Rear Stop lamp not working |1.2.1b| | 12 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 12 |
Offside Side repeater not working |1.4.A.2c| | 12 |
Power steering malfunctioning |2.3.3a| | 11 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
Front brake disc in such a condition that it is seriously weakened | 11 |
Offside Rear Stop lamp not working |1.2.1b| | 11 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 11 |
Power steering component|s| leaking |2.3.3b| | 11 |
Rear fog lamp tell tale not working |1.3.1b| | 10 |
Brake pedal spongy |3.3.B.1b| | 10 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 10 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 10 |
Rear fog lamp not working |1.3.2b| | 10 |
Parking brake: efficiency below requirements |3.7.D.4| | 10 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 9 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 9 |
Offside Headlamp not working on main beam |1.7.5a| | 9 |
Offside Front Side repeater not working |1.4.A.2c| | 9 |
Exhaust system not adequately supported |7.1.1| | 9 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Registration plate issues | 9 |
Nearside Headlamp not working on main beam |1.7.5a| | 8 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Steering box has a significant oil leak |2.2.D.2e| | 8 |
Offside rear brake recording little or no effort |3.7.B.5a| | 8 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 8 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 8 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 7 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 7 |
Rear Exhaust system not adequately supported |7.1.1| | 7 |
Windscreen has damage | 7 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Offside Rear Rear fog lamp not working |1.3.2b| | 7 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 7 |
Rear Mechanical brake component has restricted free movement | 6 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 6 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 6 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 6 |
Fuel tank leaking |7.2.3| | 6 |
Stop lamp not working |1.2.1b| | 6 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
Horn not loud enough to be heard by another road user |1.6.2b| | 6 |
Centre Exhaust system not adequately supported |7.1.1| | 5 |
Fuel pipe leaking |7.2.3| | 5 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 5 |
Nearside Front Side repeater not working |1.4.A.2c| | 5 |
Brake hose excessively deteriorated | 5 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 5 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 5 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
Steering system excessively tight |2.2.D.1| | 5 |
Nearside Front Direction indicator not working |1.4.A.2c| | 5 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 5 |
Centre Stop lamp not working |1.2.1b| | 5 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 4 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 4 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
Bonnet cannot be secured in the closed position |8.4.1| | 4 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Hazard warning lamps inoperative |1.4.B.1b| | 4 |
Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 4 |
Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 4 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 4 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
Nearside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 4 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
Headlamp switch faulty |1.7.1| | 4 |
Front brake application uneven | 4 |
Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 4 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Offside Front Brake pipe kinked |3.6.B.2b| | 4 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 4 |
Offside Front Statutory seat belt missing |5.1.1| | 4 |
Emissions not tested |7.0| | 4 |
Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 4 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 4 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 4 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 4 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 4 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 4 |
Nearside Parking brake recording little or no effort |3.7.D.3a| | 4 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Offside Front coil spring fractured |2.4.C.1a| | 4 |
Brake pipe inadequately clipped |3.6.B.1| | 3 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
Rear Stop lamp not working |1.2.1b| | 3 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Offside Front Power steering component|s| leaking |2.3.3b| | 3 |
Nearside Front Obligatory mirror insecure |8.1.1| | 3 |
Rear fog lamp switch faulty |1.3.1a| | 3 |
rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 3 |
Position lamp switch insecure |1.1.A.1| | 3 |
Brake hose has insufficient room to move | 3 |
Front Fuel system component leaking |7.2.3| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 3 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 3 |
Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Brake servo vacuum pipe deteriorated |3.6.C.1b| | 3 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 3 |
Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside Headlamp insecure |1.7.3| | 3 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
Fuel system component insecure |7.2.1| | 3 |
rear brakes release unevenly |3.7.B.4| | 3 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 2 |
Offside Intermediate drop arm insecure |2.2.B.1a| | 2 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Nearside Front coil spring broken |2.4.C.1a| | 2 |
Offside Front suspension locking device ineffective |2.5.A.4| | 2 |
Nearside Front Direction indicator insecure |1.4.A.2b| | 2 |
Offside Front Steering box has a significant oil leak |2.2.D.2e| | 2 |
Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Offside Steering pivot point has excessive play |2.2.B.1g| | 2 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
Offside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 2 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Nearside Outer Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Front Steering system excessively tight |2.2.D.1| | 2 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Stop lamp remains on when the brakes are released | 2 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Nearside Front Shock absorber insecure |2.7.2b| | 2 |
Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 2 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Offside Front brake disc contaminated by brake fluid |3.5.1h| | 2 |
Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 2 |
Nearside Front Upper Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 2 |
Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Power steering fluid level below minimum |2.3.1| | 2 |
Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Nearside Front Direction indicators not working |1.4.A.2c| | 2 |
Offside Front Front suspension locking device missing |2.5.A.4| | 2 |
Nearside Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Rear Brake cable insecure | 2 |
Offside Rear An item not tested |Manual| | 2 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Brake hose excessively damaged |3.6.B.4d| | 2 |
Nearside Rear rear brake juddering severely |3.7.A.5b| | 2 |
Brake pipe fouled by moving parts |3.6.B.2a| | 2 |
Offside Front Axle king pin retaining device missing |2.5.A.3a| | 2 |
Nearside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 2 |
Offside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 2 |
Offside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 2 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
Nearside Rear Statutory seat belt missing |5.1.1| | 2 |
Offside Rear Statutory seat belt missing |5.1.1| | 2 |
Steering box insecure |2.2.B.1a| | 2 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Front Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
Nearside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Offside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 2 |
Brake cable locking device missing |3.5.1l| | 2 |
Nearside Inner Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Inner Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Nearside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 2 |
Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Front suspension locking device missing |2.5.A.4| | 2 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 2 |
Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
Fuel system component leaking in engine bay |7.2.3| | 2 |
Nearside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front Battery insecure |1.9.1| | 2 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front Steering locking device missing |2.2.C.1g| | 2 |
Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front coil spring broken |2.4.C.1a| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Nearside Outer Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Steering pivot point has excessive play |2.2.B.1g| | 2 |
Windscreen wiper blade insecure | 2 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
Rear fog lamp switch missing |1.3.1a| | 2 |
Electrical wiring inadequately supported |1.9.2a| | 2 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Rear Statutory seat belt missing |5.1.1| | 2 |
Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 2 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
Offside Front suspension has excessive play in a lower wishbone bearing |2.5.B.1a| | 2 |
Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
Front Horn not a continuous or uniform sound |1.6.2e| | 2 |
Brake hose damaged | 2 |