| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 85 |
| Parking brake: efficiency below requirements |3.7.B.7| | 63 |
| Registration plate lamp issues | 62 |
| Headlamp aim out of alignment | 55 |
| Brake hose excessively deteriorated | 49 |
| Brake pipe excessively corroded | 40 |
| Rear parking brake recording little or no effort | 29 |
| Nearside Stop lamp not working |1.2.1b| | 29 |
| Offside Stop lamp not working |1.2.1b| | 18 |
| Registration plate issues | 14 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 14 |
| Brakes imbalanced across an axle | 13 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 13 |
| Horn not working |1.6.2a| | 13 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 13 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 12 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 12 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 11 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 11 |
| Parking brake lever has no reserve travel |3.1.6b| | 9 |
| Front brake application uneven | 9 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 8 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Nearside Rear Stop lamp not working |1.2.1b| | 7 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 7 |
| Rear brake disc in such a condition that it is seriously weakened | 6 |
| Windscreen has damage | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Rear brake binding | 6 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 5 |
| Brake hose has insufficient room to move | 5 |
| Nearside Headlamp not working on main beam |1.7.5a| | 5 |
| Hazard warning switch faulty |1.4.B.1d| | 5 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 5 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Emissions not tested |7.0| | 4 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 4 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 4 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Brake hose damaged | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Front brake excessively fluctuating | 3 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear brake disc excessively pitted |3.5.1h| | 3 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Towbar excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 3 |
| Offside Front coil spring broken |2.4.C.1a| | 3 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Windscreen wiper blade insecure | 3 |
| Offside Side repeater incorrect colour |4.4.3 |a|| | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 2 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3) | 2 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 2 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 2 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 2 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 2 |
| Windscreen washer not working | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 2 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside front brake juddering severely |3.7.A.2b| | 2 |
| Offside front brake juddering severely |3.7.A.2b| | 2 |
| Nearside Rear Towbar excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 2 |
| Power steering malfunctioning (2.1.5 (a)) | 2 |
| Nearside Front Electrical wiring inadequately supported |1.9.2a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3) | 2 |
| Parking brake: efficiency below requirements (3.7.B.7) | 2 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| front brakes release unevenly |3.7.B.4| | 2 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 2 |
| Bonnet cannot be secured in the closed position |8.4.1| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |