Most common failures | No# failures |
---|
Registration plate lamp issues | 30 |
Headlamp aim out of alignment | 29 |
Parking brake: efficiency below requirements |3.7.B.7| | 27 |
Windscreen wiper does not clear the windscreen effectively | 19 |
Rear parking brake recording little or no effort | 13 |
Parking brake lever has no reserve travel |3.1.6b| | 11 |
Brake pipe excessively corroded | 11 |
Offside Rear fog lamp not working |1.3.2b| | 10 |
Brake hose excessively deteriorated | 10 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
Brakes imbalanced across an axle | 9 |
Registration plate issues | 9 |
Offside Stop lamp not working |1.2.1b| | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Brake load sensing valve linkage seized |3.6.E.3| | 5 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
Anti-lock braking system warning lamp indicates an ABS fault | 5 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
Brake load sensing valve seized |3.6.E.3| | 4 |
Nearside Rear Stop lamp not working |1.2.1b| | 4 |
Windscreen has damage | 4 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 3 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Front brake disc in such a condition that it is seriously weakened | 3 |
Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 3 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 2 |
Fuel cap/sealing device missing |7.2.4a| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 2 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
Horn not working |1.6.2a| | 2 |
Rear fog lamp switch insecure |1.3.1a| | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Rear fog lamp switch not able to be operated from the normal driving position |1.3.1a| | 1 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Emissions not tested due to poor running (8.2.1.2 (d)) | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Power steering component leaking (2.1.5 (a)) | 1 |
Rear reflector missing x2 (4.8.2 (a) (ii)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Horn control missing |1.6.1| | 1 |
Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Front brake disc excessively scored |3.5.1h| | 1 |
Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Front Anti-roll bar linkage inappropriately repaired |2.4.A.2| | 1 |
Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Emissions not tested |7.0| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Centre Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Horn control insecure |1.6.1| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Nearside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced front and rear of sills both sides weak due to corrosion (6.1.1 (c) (i)) | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Power steering pump leaking from a failed component |2.3.3b| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Front brake application uneven | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Centre Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
Offside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Centre Windscreen wiper control missing |8.2.1a| | 1 |
Centre Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Centre Exhaust mounting missing |7.1.1b| | 1 |
Offside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Rear Rear fog lamp switch missing |1.3.1a| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Electrical wiring insecure ecu |1.9.2a| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Brake servo leaking |3.6.C.1c| | 1 |
Front Leaf spring fractured |2.4.B.1a| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Windscreen wiper blade insecure | 1 |
Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear Lower All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Brake pivot has restricted free movement |3.5.1k| | 1 |
Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear brake caliper securing device missing |3.5.1j| | 1 |
Nearside Windscreen wiper blade missing |8.2.2| | 1 |
Nearside Front brake disc cracked |3.5.1h| | 1 |
Offside Front brake disc cracked |3.5.1h| | 1 |
Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Parking brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Parking brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Windscreen wiper blade missing |8.2.2| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect fit bulb correctly (4.1.2 (c)) | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Rear fog lamp switch insecure (4.5.3 (a)) | 1 |
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Brake load sensing valve seized but ABS functioning linkage (1.1.17 (c) (i)) | 1 |
Power steering pipe/hose leaking small pipe one rack (2.1.5 (a)) | 1 |
Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill behind rear wheel (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill behind rear wheel (5.3.6 (a) (i)) | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |