| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Registration plate lamp issues | 5 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Rear reflector missing |1.5.1a| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Rear Brake load sensing valve seized |3.6.E.3| | 2 |
| Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Front Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Nearside Front Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Battery insecure |1.9.1| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Access panel cannot be secured in the closed position fuel tank access panel |6.4.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage Body holed / damaged |6.1.C.1| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Nearside Rear reflector insecure |1.5.1a| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Front Braking system leaking (1.1.3 (d)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Position lamp not working Side marker inop x2 (4.2.1 (a) (ii)) | 1 |
| Offside Position lamp not working Side marker inop (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Outline marker lamp not working side marker (4.2.1 (a) (ii)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing holed (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing holed (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger holed at body mounting (5.3.6 (a) (i)) | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Exhaust has a major leak of exhaust gases blowing at silencer (6.1.2 (a)) | 1 |
| Offside Rear Shock absorbers insecurely attached top bolt loose (5.3.2 (a) (i)) | 1 |
| Offside Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Fuel pipe leaking |7.2.3| | 1 |
| Brake load sensing valve inoperative and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Rear Body component corroded and likely to cause injury Tail lift |6.2.1 |a| |i|| | 1 |
| Nearside Front Cab steps so insecure it is likely to cause injury Corrosion underneath |6.2.8 |a| |ii|| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Speedometer cannot be illuminated |7.8 |c| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Outline marker lamp not working x2 |4.2.1 |a|| | 1 |
| Offside Outline marker lamp not working x3 |4.2.1 |a|| | 1 |
| Nearside Rear Upper Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Upper Outline marker lamp not working |4.2.1 |a|| | 1 |
| Exhaust has a major leak of exhaust gases Silencer around bracket |6.1.2 |a|| | 1 |
| Nearside Body component corroded and likely to cause injury Side rail |6.2.1 |a| |i|| | 1 |