| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 6 |
| Registration plate lamp issues | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Braking system leaking (1.1.3 (d)) | 1 |
| Drag link end ball joint has excessive play marked (2.1.3 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases centre box and downpipe (6.1.2 (a)) | 1 |
| Seat belt flexible stalk damaged likely to lead to failure under load drivers stalk |5.2.4a| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining pressure on the sealing arrangement |6.7.2a| | 1 |
| Nearside Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Rear Front position lamp|s| not working top markers front and rear |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working top and bottom brake lights |1.2.1b| | 1 |
| Central Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Exhaust system not adequately supported hook insecure and too short |7.1.1| | 1 |
| Nearside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded b post inner corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Rear fog lamp not in good working order |not working| |1.1.6b| | 1 |
| Rear Stop lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Offside Rear Upper Stop lamp not in good working order |function impaired| |1.3.2b| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear Passenger`s seat with a defective structure |6.2.6 |a| |i|| | 1 |
| Brake performance not tested |3.8| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Transmission brake efficiency below requirements |3.8.A.9/10| | 1 |
| Nearside Rear Upper All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Seat belt stitching badly frayed |5.1.B.3c| | 1 |
| Nearside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Emission control equipment obviously defective EDC light on electronic diesel control fault |8.2.2.1 |a|| | 1 |
| Nearside Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Offside Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength rear (5.3.6 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Seat belt anchorage prescribed area is inadequately repaired Both inner sills |5.2.6| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Seat belt has a cut which has significantly weakened the webbing MIDDLE REAR SEAT |5.2.2a| | 1 |