| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Registration plate issues | 2 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Rear parking brake recording little or no effort | 1 |
| Rear brake binding | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Outer Drive shaft joint excessively worn driveshaft leaking and no longer prevents the ingress of dirt |6.1.7 |c| |i|| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |
| Rear fog lamp switch faulty not work |1.3.1a| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear Rear reflector missing offside and nearside (4.8.2 (a) (ii)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Steering locking device missing drop arm (2.1.3 (d)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |