| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 21 |
| Brake pipe excessively corroded | 19 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Direction indicators incorrect colour |1.4.A.2f| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Registration plate lamp issues | 4 |
| Front Exhaust system not adequately supported |7.1.1| | 4 |
| Nearside Front coil spring fractured |2.4.C.1a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Battery insecure |1.9.1| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Registration plate issues | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
| Emissions not tested |7.0| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Windscreen has damage | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front All direction indicators incorrect colour |4.4.3 |a|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Brake pipe inadequately supported |3.6.B.1| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Nearside Rear Wheel stud|s| loose |4.2.A.1e| | 1 |
| Nearside Front Wheel stud|s| loose |4.2.A.1e| | 1 |
| Offside Front Wheel stud|s| loose |4.2.A.1e| | 1 |
| Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Fuel pipe insecure |7.2.1| | 1 |
| Offside Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Wheel stud|s| missing |4.2.A.1e| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Direction indicator incorrect colour discoloured |4.4.3 |a|| | 1 |
| Offside Front Floor excessively deteriorated corroded |6.2.4 |a| |i|| | 1 |
| Offside Rear Road wheel distorted |4.2.A.1a| | 1 |
| Front brake application uneven | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Lower Suspension arm damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Ball joint ball pin shank loose |2.2.B.1c| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Nearside Front Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |