| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 31 |
| Brake pipe excessively corroded | 27 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 15 |
| Registration plate issues | 14 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 6 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 3 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Road wheel fractured |5.2.2 |a|| | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Emissions unable to be completed (8.2.1.2 (d)) | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Road wheel cracked |4.2.A.1a| | 1 |
| Offside Rear Road wheel fractured Inner face |5.2.2 |a|| | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative Both sides |4.1.6 |a| |ii|| | 1 |
| Nearside Front Road wheel cracked inner |4.2.A.1a| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Rear Air suspension bellows leaking |2.4.D.2| | 1 |
| Nearside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt drop link |5.3.4 |b| |ii|| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Supplementary restraint system warning lamp indicates a fault air bag fault (7.1.6 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Windscreen has damage | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Parking brake inoperative on one side rear hand brake low performance righ side low (1.4.1 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt rubber boot split leaking grease (5.3.4 (b) (ii)) | 1 |
| Nearside Brake pipe leaking on an air braking system front to rear above axle (1.1.11 (b) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Offside Front Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Offside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Bonnet seriously at risk of opening inadvertently (3.1 (b) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Rear Brake cable insecure | 1 |
| Rear Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Offside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Emission control equipment obviously defective (8.2.1.1 (a)) | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front Brake lining(s) less than 1.5 mm thick Both (1.1.13 (a) (ii)) | 1 |
| Nearside Rear Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt both (5.3.4 (b) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Brake pipe excessively damaged (1.1.11 (c)) | 1 |