| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 12 |
| Headlamp aim out of alignment | 7 |
| Registration plate lamp issues | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Brake pipe excessively corroded | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Brake hose excessively deteriorated | 3 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Fuel pipe leaking |7.2.3| | 1 |
| Offside Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Brake vacuum build up too slow |3.3.E.6| | 1 |
| Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Lower Leaf spring anchor pin or bush excessively worn Rear (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Leaf spring shackle pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Front Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear fog lamp does not emit a steady red light white light (4.5.4 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases silencer holed (6.1.2 (a)) | 1 |
| Central Rear Exhaust system insecure pipe cracked and slight leak (6.1.2 (a)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Front Front passenger door does not latch securely closed (6.2.3 (a)) | 1 |
| Trailer electrical socket wiring insulation damaged or deteriorated and likely to cause a short-circuit (4.10 (b) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear reflector missing |1.5.1a| | 1 |
| Nearside Outer Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Body has a sharp edge caused by corrosion bonnet holed |6.1.C.1| | 1 |
| Nearside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wing |6.1.B.2| | 1 |
| Nearside Front Body insecure and dangerous to other road users wing |6.1.B.1b| | 1 |
| Offside Front Body insecure and dangerous to other road users wing |6.1.B.1b| | 1 |
| Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt Drag Link |2.2.C.1c| | 1 |
| Offside Front Body has a sharp edge caused by corrosion Floor Pan Holed |6.1.C.1| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Step (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Step (6.2.2 (d) (i)) | 1 |
| Nearside Rear Outer Sub-frame corroded and seriously weakened Various (5.3.3 (b) (i)) | 1 |
| Offside Rear Outer Sub-frame corroded and seriously weakened Various (5.3.3 (b) (i)) | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Centre Exhaust system not adequately supported mount broken |7.1.1| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Stop lamp insecure |1.2.1a| | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Indicator tell tale inoperative Right hand tell tale |1.4.A.2a| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Nearside Front Outer Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced under step |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch |7.1.1 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced under step |7.1.1 |a| |i|| | 1 |
| Nearside Front Body mounting fixings insecure such that stability is seriously impaired body mount corroded and holed |6.2.2 |c| |ii|| | 1 |
| Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Front Fuel system component leaking |6.1.3 |b| |i|| | 1 |
| Exhaust fumes causing a danger to health of persons on board |6.1.2 |b| |ii|| | 1 |
| Offside Body panel corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Power steering malfunctioning |2.1.5 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Brake hose bulging under pressure |1.1.12 |d|| | 1 |
| Offside Front Brake hose bulging under pressure |1.1.12 |d|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Power steering malfunctioning Not working consistently (2.1.5 (a)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Drivers step holed and corroded (6.2.2 (d) (i)) | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Corroded and holed mounts along offside (6.2.2 (d) (i)) | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Corroded and holed along nearside (6.2.2 (d) (i)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Rear Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wing under bonnet |6.1.B.2| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |