| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Registration plate lamp issues | 7 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Rear parking brake recording little or no effort | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Brakes imbalanced across an axle | 4 |
| Horn not working |1.6.2a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Registration plate issues | 3 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 3 |
| Front brake application uneven | 3 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Headlamp aim out of alignment | 2 |
| Nearside Front Seat belt insecurely fixed to the seat |5.2.1a| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt Both ends |2.2.C.1c| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front passenger seat insecure |6.2.3| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Centre Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Side repeater incomplete |1.5.A1b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front Power steering malfunctioning |2.3.3a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Windscreen has damage | 1 |
| Rear Towbar mounting obviously of an inappropriate type |6.6.2| | 1 |
| Rear Towbar fixing obviously of an inappropriate type |6.6.2| | 1 |
| Nearside Front Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Lower Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Spare wheel carrier insecure |6.4.2| | 1 |
| Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Rear Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Drivers seat with a defective structure base corroded and broken (6.2.5 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is inadequately repaired and functionality of the braking system is affected repaired with fibreglass (1.1.21 (e) (ii)) | 1 |
| Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded and functionality of the braking system is affected (1.1.21 (e) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced lower seat base corroded and broken (7.1.1 (a) (i)) | 1 |