| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Registration plate lamp issues | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 2 |
| Registration plate issues | 2 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Braking system leaking Air On Handbrake System |1.1.3 |d|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Body panel damaged and likely to cause injury side panel missing and showing sharp edges (6.2.1 (a) (i)) | 1 |
| Rear Body panel damaged and likely to cause injury rear panel broke off and showing sharp edges (6.2.1 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases down pipe holed and corroded (6.1.2 (a)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Offside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear position lamp|s| not working all |1.1.A.3b| | 1 |
| Anti-roll bar linkage has excessive play in a pin/bush both rear |2.4.G.2| | 1 |
| Offside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Centre Rear Emergency exit door cannot be opened from inside the vehicle |6.2.D.1a| | 1 |
| Centre Rear Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 1 |
| Emergency exit window ???break glass` hammer missing |6.2.D.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Emergency exit door cannot be opened from inside the vehicle |6.2.D.1a| | 1 |
| Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Windscreen washer not working | 1 |
| Floor in such a condition it is likely to cause load insecurity or instability passenger floor frame corroded and insecure |6.2.4 |a| |ii|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Lower Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Direction indicator not in good working order |not working| |1.5.1b| | 1 |
| Nearside Front Fuel system component leaking |7.2.3| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
| Offside Front Inner Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Front Outer Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.5.11a| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Nearside Rear Leaf spring fractured front eye fractured (5.3.1 (b) (i)) | 1 |
| Offside Front Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust has a major leak of exhaust gases silencer |6.1.2 |a|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction sun visor |3.1 |a| |ii|| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.6| | 1 |