| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Brakes imbalanced across an axle | 8 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Rear brake application uneven | 4 |
| Windscreen washer not working | 4 |
| Registration plate lamp issues | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Emissions not tested |7.0| | 3 |
| Front brake application uneven | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Registration plate issues | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Brake pipe excessively corroded | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working upper & lower (4.4.1 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both kicker wrong way (4.1.2 (c)) | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Headlamp aim aimed so that it dazzles other road users both |1.8.A.1a| | 1 |
| Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired |6.2.2 |d| |ii|| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Offside Steering arm modified such that the steering is adversely affected loose to hub (2.1.3 (f) (ii)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Front passenger door hinge deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicators not working connection |1.4.A.2c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Central Subframe mounting prescribed area is excessively corroded cross member between chassis |2.4.A.3| | 1 |
| Fuel cap/sealing device missing new cap fitted |7.2.4a| | 1 |
| Nearside Front Front position lamp|s| not working fuse |1.1.A.3b| | 1 |
| Nearside Front Rear position lamp|s| not working fuse |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Stop lamp not working Both |1.2.1b| | 1 |
| Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid Master cylinder "Corroded" |3.6.A.1| | 1 |
| Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt All X4 |2.2.C.1c| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp insecure inside lamp hi/low (4.1.1 (c)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Body panel corroded and likely to cause injury above wheel arch (6.2.1 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step (7.1.1 (a) (i)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kick up is to the right. (4.1.2 (c)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Kick up is to the right. (4.1.2 (c)) | 1 |
| Fuel system component leaking Fuel leak in the area of fuel tank & associated piping. (6.1.3 (b) (i)) | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Position lamp switch missing |1.1.A.1| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Brake pipe connection leaking on a hydraulic braking system along chassis near gearbox (1.1.11 (b) (ii)) | 1 |
| Offside Front Lower Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Rear fog lamp missing the 1 rear fog lamp which must be fitted to the centre or offside of vehicles first used on or after 1 April 1980 (4.5.1 (a) (ii)) | 1 |
| Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Towbar component excessively corroded |6.6.1| | 1 |
| Towbar support obviously of an inappropriate type |6.6.2| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Centre Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Front passenger seat insecure |6.2.3| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust system insecure mounting broken |6.1.2 |a|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Rear Body mounting fixings insecure crossmembers corroded at body mountings nearside and offside /2x crossmembers |6.2.2 |c| |i|| | 1 |
| Nearside Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Seat belt affected by an insecure seat fixing passangers front |5.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |