| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Registration plate lamp issues | 7 |
| Registration plate issues | 7 |
| Brake pipe excessively corroded | 5 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Brake hose excessively deteriorated | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Brakes imbalanced across an axle | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Horn not working |1.6.2a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear brake binding | 1 |
| Rear parking brake recording little or no effort | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear brake disc cracked |3.5.1h| | 1 |
| Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Emissions not tested Exhaust system defect |8.2.1.2 |d|| | 1 |
| Exhaust has a major leak of exhaust gases Middle box & possibly elsewhere |6.1.2 |a|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Lower Passenger`s seat insecure |6.2.A.1| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Windscreen wiper blade missing |3.4 |b| |ii|| | 1 |
| Nearside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen has damage | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Exhaust system insecure rear mounts broken (6.1.2 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Emissions not tested due to burst leaking exhaust (8.2.1.2 (d)) | 1 |
| Central Front Body component corroded and likely to cause injury bumper corroded/cracked and holed (6.2.1 (a) (i)) | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Rear Service brake excessively fluctuating both rear (1.2.1 (e)) | 1 |
| Central Exhaust has a major leak of exhaust gases exhaust corroded/holed above and below silencer [y]sections (6.1.2 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area fractured significantly reducing structural strength corroded/holed at bottom of inner arch (5.3.6 (a) (i)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Central Exhaust has a major leak of exhaust gases exhaust corroded/holed at mid silencer [y] joints (6.1.2 (a)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |