| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 36 |
| Headlamp aim out of alignment | 30 |
| Windscreen wiper does not clear the windscreen effectively | 25 |
| Parking brake: efficiency below requirements |3.7.B.7| | 20 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Registration plate issues | 11 |
| Registration plate lamp issues | 10 |
| Anti-lock braking system warning lamp indicates an ABS fault | 10 |
| Nearside Side repeater not working |1.4.A.2c| | 8 |
| Rear parking brake recording little or no effort | 8 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
| Rear brake binding | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Offside Front coil spring fractured |2.4.C.1a| | 6 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Offside Rear coil spring fractured |2.4.C.1a| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Brake hose excessively deteriorated | 5 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Windscreen has damage | 4 |
| Windscreen wiper blade insecure | 3 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 3 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Front coil spring cracked |2.4.C.1a| | 3 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear Upper Suspension arm insecure |2.4.G.1| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Upper Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Outer Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Rear Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Rear Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Seat belt not functioning as intended Not retracting |7.1.2 |c|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear Fuel hose insecure 2x fuel pumps and filter |6.1.3 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Lower Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Upper coil spring cracked |2.4.C.1a| | 1 |
| Offside Front Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Offside Rear Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear coil spring cracked |2.4.C.1a| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Outer Rear Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Rear Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Rear Lower Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Rear Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated Pull release handle missing (1.1.6 (d)) | 1 |
| Offside Lower Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction Sticker (3.1 (a) (ii)) | 1 |
| Nearside Rear Road wheel more than one fixing loose (5.2.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |